Professional Documents
Culture Documents
I. Materials
Needed softwares:
Click the Flash! button and wait for the process to finish.
NOTE:
If you encounter prompts about formatting your sd card, just click Cancel.
III. Configuration
IMPORTANT:
Make sure you do the following before turning on the raspberry:
Connect the entire connections base on the circuit diagram. Make sure to check the positive and negative
terminal of the 12V DC power supply for the coinslot to work properly.
Materials
1x 5 Volts Single Channel Relay Module
1x 2N2222 Transistor
1x 4.7K Ohm Resistor
12v Led SMD light (optional)
Materials
1x 5 Volts Single Channel Relay Module with Octotupler
2x 1K Ohm Resistor
1x 3V LED (Green)
1x 3V LED ( Red)
Please watch video below to know the purpose of relay in your diagram or DIY