Professional Documents
Culture Documents
BDM100
On Trucks And Commercial Vehicles
Table of Contents
Titel: Page:
Preface............................................................................................................ 3
The BDM100 Module ...................................................................................... 3
Connecting to BOSCH EDC7 ECUs .............................................................. 4
Powering the BOSCH EDC7 ECUs ............................................................... 5
Connecting to Motorola EDC S6 ................................................................... 6
Connecting to Motorola / Cummins CM850 ................................................. 7
Connecting to TRW EMS2 ECUs .................................................................. 8
Connecting to John Deere L14 ECUs ........................................................... 9
Connecting to Delphi / DAF ECUs ...............................................................10
Connecting to Delphi / ISUZU ECUs ............................................................11
The Alignment of the BDM-Port Pads .........................................................12
Pin Out BDM100 Module ..............................................................................13
Pin Out BOSCH System Programming Pads ..............................................13
Some ECUs on Trucks with BDM capability ...............................................14
Disclaimer / Warranty
The BDM module is for use by qualified personnel only. A warranty on our part for direct
damages and consequential damages, caused by the improper handling of our product or
additional products is excluded.
The interconnection between the BDM100 Module and the appropriate ECU is very easy.
Nevertheless you should read this manual carefully, because any failure may result in the destruction
of the ECU.
! To avoid damages on your BDM100-module or on an ECU, please carefully read this manual
before you start running the BDM100 Module with an ECU !
Pict. 10: The main connector of the John Deere L14 ECU.
1st. step:
2nd. step:
2 4 6 8 10
3rd. step:
1 3 5 7 9
* with this ECUs an external power supply is required. In the case of using a professional laboratory
power supply the knowledge of the main connector pinout of the ECU is neccessary.
Although we were efforted to describe all details with the highest possible precision, nevertheless we
can not guarantee an errorfree content of this manual.
.