Professional Documents
Culture Documents
2020 -02-29
Product Price
Profarma 15
Report 400
Audrino 480
Flex Sensor (x4) 1400
Sensor Sheild 200
L.C.D (16x2) 120
HC-05 290
I2C 90
Bread Board 60
Relay Module 120
Jumper (M to F) 50
7.4v Li-ion
Battery 450
D.C pin 10
Glue gun 80
5V-1A Adaptar 60
L.C.D (New Part) 176
Gloves 179
Total 4180
COMPONENT DISCRIPTION
Sensor Shield
Arduino Sensor Shield is a low-cost board that allows you to connect a range of sensors to your
Arduino using easy-to-attach jumper cables.
It’s a simple board with no electronics on it other than a couple of resistors and an LED.
Its main role is to supply those header pins to make it easier to attach external devices like our
servo motors.
Features:
• The Arduino Sensor Shield V5.0 allows plug and play connection to various modules like
sensors, servos, relays, buttons, potentiometers and more
• Suitable for Arduino UNO and Mega Boards
• IIC interface
• Bluetooth module communication interface
• SD card module communication interface
PROJECT REVIEW REPORT
2020 -02-29
HC-05
HC-05 module is an easy to use Bluetooth SPP (Serial Port Protocol) module, designed for
transparent wireless serial connection setup.
Serial port Bluetooth module is fully qualified Bluetooth V2.0+EDR (Enhanced Data Rate)
3Mbps Modulation with complete 2.4GHz radio transceiver and baseband. It uses CSR
Bluecore 04-External single chip Bluetooth system with CMOS technology and with
AFH(Adaptive Frequency Hopping Feature). It has the footprint as small as 12.7mmx27mm
PROJECT REVIEW REPORT
2020 -02-29
Hardware Features
Software Features
Default Baud rate: 38400, Data bits:8, Stop bit:1,Parity:No parity, Data control: has.
Supported baud rate: 9600,19200,38400,57600,115200,230400,460800.
7.4V 2600mAh High Capacity Lithium ion battery pack, Maintain 60% capacity for 1000 ti.mes
of cyclic charging, and increase the cycle life by 50% compared with NIMH. 2、Length: 2.68
inch, Width:1.46 inch, Height: 0.75 inch
5V-1A Adaptar
5 Volt 1 Amp Power Adapter takes an AC INPUT of 100-240V and gives 5V 1A DC output
It is used for charging 7.4v battery
2
PROJECT REVIEW REPORT
2020 -02-29
PROBLEM FACED
1. Lcd module was not working properly so we used potentiometer to increase the intensity
of lcd back light but still it was not working fine
After some time period the lcd was totally got scraped so we got new lcd and started
working on it.
2. Coding problem also occurred we are currently solving and doing further changes in
our product
3. Flex sensors were having some faulty measures while performing the operation. We
made our operation accordingly
1. Bluetooth Module(HC05): we are not able to pass audio through android to arduino
board. connection from android phone to arduino board is happening only problem
here is how to pass audio from mobile to ardino and then that audio will get converted
into text format and will be visible on LCD display
Project is still under working process project is only completed 60-70% of overall 100%
PROJECT REVIEW REPORT
2020 -02-29