Professional Documents
Culture Documents
Tonepad Rodymod
Tonepad Rodymod
Rev.5.Mar.13.2002
When there’s a board that can be populated as two very famous effects, the question always is “which
effect should I build on this board?” To help with this issue, here’s a mod that involves adding a 4 pole
double throw toggle switch so that you don’t have to make that decision. Populate the board with the
resistors for the Rosscomp, but leave the capacitors out. Instead, solder wire leads to the pads
marked on the layout below. Take the switch and solder the caps to it, all the negative leads of the
electrolytics go to ground, and the positives go to the respective poles. Switch ON: you get Ross,
Switch OFF: Dyna. MXR and Dynacomp are registered trademarks owned by Dunlop.
500k 50k
D3
10k
D2 10k
Q4 Q5
Q3
D1
0.05
0.01
27k
1M
1M 0.01 +
GND Cd
10uF
IN 0.01 10k OUT
4M7 0.001 Q2
1uF
27k 150k
IC 1
+
10uF
56k 0.01
1uF
+
15k
0.01 1M
10k
Rb
Re
Rd
1M
Ca
Cc
+
2k
1uF
Rc
Ra trim
Cb
+
10k
Q1
Cd
NC
Cc
http://www.tonepad.com
NC
4PDT
SW