You are on page 1of 4

Tanveer Hussain

Tel: +639953754531 / WhatsApp: +923336640113 Email: tanveer13092@gmail.com

Objective:

Over 7 years in field of Telecommunication, extensive experience of 4G/3G/2G network optimization/planning on


Huawei, ZTE equipment.

Professional Experience:

 RF optimization engineer on Huawei-Globe expansion project Philippine.


 Worked as RF optimization engineer on Huawei (Celcom Hammer 2) capacity upgrade, layer addition sites
project Malaysia.
 Worked as RF optimizer on ZTE (UMobile) antenna swap and layer addition project Malaysia.
 Worked as RF optimizer / OSS Engineer on Huawei (Celcom) MCMC T3 Project Malaysia.
 Worked as RF optimizer on Huawei (Celcom) hammer1 CBO project Malaysia.
 Worked as RF optimizer on Huawei (Omantel) antenna modernization project Oman.
 Worked as team lead / reporting and analysis on Huawei (CMPak) LTE rollout south Pakistan.

Work and Key Responsibilities:

Company Name: Glotech International, Philippine (April-2019 to continue)


Job Title: RF Engineer
Project: Huawei (Globe Expansion)
 Responsible for the Customer end Approval of 2G, 3G and 4G SSV and OSS reports.
 Monitor all 2G, 3G, LTE and massive MIMO hourly/Daily KPI’s.
 Handling NCR, NLZ and SLZ region roll out sites.
 Perform routine Optimization to improve main KPI’s RRC Success Rate, ERAB Success Rate, ERAB Drop
Rate & Handovers & UL / DL Throughput etc.
 KPI improvement of 2G, 3G and LTE cells
 Alarm troubleshooting and clearing
 Root cause analysis of KPI degradation
 Physical optimize of the roll out sites to improve the SINR and DL throughput.
 Traffic balancing, PRB balancing.
Work and Key Responsibilities:

Company Name: Tinnovatik Sdn Bhd Malaysia (Aug-2016 to 25-April-2019)


Job Title: LTE RF Engineer
Project: Huawei Celcom
 Working as a 4G RF Optimization Engineer on Celcom Project since August 2016.
 Stats monitoring on daily basis for new sites and capacity upgrade sites.
 Daily KPIs monitoring, worst cell analysis and proposal to improve failure KPIs.
 Improve coverage by Physical audit and also as well soft parameter.
 Analyze Cluster Pre Post Report and make Plane to improve them.
 Drive test data to be used for both real time optimization and detailed analysis by using NEMO
Analyzer, U2000, PRS, Naster.
 Data Drive test log file analysis to improve data network performance by checking the Coding Schemes ,
Modulation & optimizing bad coverage & bad quality areas for Improvement in DL Throughput.
 Analyze and giving recommendation for critical KPIs likes DL Throughput, Hard & Soft Blocking.
 CBO(Cluster base optimization)- 2G-RxLev/RxQual,3G-EcNo/RSCP/Pilot Pollution,4- SINR/RSRP/Cell
Overlapping/DL & UL Throughput.
 PRB Utilization balancing, User balancing.
 Coordinate activities of optimization such as cleaning of non-necessary neighbors, optimization of
3G-3G and 3G-2G neighbors, check of active set size required for different sectors taking into account
drive tests and statistics.
 CA carrier balancing, Load Balancing.
 Meeting with customer for Cluster approval Report.
 Complete Analysis done by Nemo Analyzer.
 Prediction Plot simulation of clusters using U-NET.
 Analyze end to end customer complain by using Naster Tool and proposed recommendation to solve CC.
 LTE Drop Call analysis, Network Attach failure analysis, PCI collision analysis, HO failure analysis, Worst cell
analysis, PRACH failure analysis by analyzing DT logs and OSS KPIs.
 Troubleshooting of CSFB, HO and other failures through layer 3 messages.
 Hotspots analysis, layer 3 analysis and overall cluster justifications’ using NEMO Analyze and Nastar.
Work and Key Responsibilities:

Company Name: Tinnovatik Sdn Bhd Malaysia


Job Title: RF Engineer
Project: ZTE-LTE/3G Umobile antenna Swap and Layer Addition Project

 Monitor PRE Post KPI after Swap LTE/UMTS Cluster drive.


 Coordinate directly with customer and discussion each issue and getting Approval.
 Calculate LTE/ 3G KPI from DT Coverage CSSR CDR DL/UL BLER Pilot Pollution Volte CSFB.
 Troubleshooting and optimizing worst cells.
 Monitoring major 3G/LTE KPIs of assigned sites and Clusters ( CSSR , CDR, RRC setup success rate, CSFB,
ERAB success rate ,DL/UL throughput, LTE HO success rate if any KPI degraded and worst then Proposed
optimization.
 Improve coverage by Physical audit and also as well soft parameter.
 Provide LTE 3G OSS KPI Justification about IRAT, Traffic DCR etc. Optimize if possible.
 Checking 3G transmission issue before drive and if DL and achieving.
 Meeting with customer for Site Approval and justify them.
 Complete Analysis done by Nemo Analyzer.
 Troubleshooting of CSFB, HO and other failures through layer 3 messages.

Work and Key Responsibilities:

Company Name: LCC Muscat (Oman) (June 2015 to March 2016)


Job Title: RF Engineer
Project: Antenna modernization Omantel (Huawei)
 Responsible for Prepare reports (Pre drive, Post Drive, Swap drive).
 Made Pre & Post Clusters prediction coverage reports using u-net.
 Cluster report 3G, 4G and optimize overshoot sites to improve quality.
 Improve coverage by Physical audit and also as well soft parameter.
 Monitoring, analyzing statistical and drive test data to improve system performance indicators such as CSFB
Failures, IRAT handover failures and Intra frequency handover failures using Genex Assistant
 Working on Genex Assistant for analysis data in drive testing.
 Inter-RAT handover verification.
 Troubleshooting of CSFB, HO and other failures through layer 3 messages.
Work and Key Responsibilities:

Company Name: UCE International Telecom Solution, Pakistan. (Jan 2014 to June 2015)
Job Title: Team Lead / Coordinator.
Project: ZONG 4G LTE South (Huawei)
 Leading RF team of 10 engineers and 8 riggers to achieve KPIs agreed for newly integrated sites.
 Team coordination, preparing reports, observing and removing DT issues
 3G, 4G DT reports preparation.
 Cluster report and optimize overshoot sites to improve quality.
 Responsible for SSV and Cluster Final approval.
 Working on Genex Probe Assistant for analysis data in drive testing.
 Working on Genex Probe software as a drive test tool.
 Stationary call testing - CSFB verification (MT)/ (MO).
 4G -> 3G Inter-RAT handover verification.
 Intra-eNodeB handover.
 Cell reselection verification 4G->3G/3G->4G.
 Call drop Errors, throughput testing, Ping & connectivity test.

Tools Skills:

 I-Manager U2000, U2020, PRS.


 Genex Probe & Genex Assistance.
 Nemo Analyzer.
 U-Net planning tool.
 Nastar.
 Netnumen.
 Google Earth, MS Office.
 Tems 8.0.4, TEMS 15.3.3.
 MapInfo, Actix.

Education:

BE, Electronics Engineering (Recognized by PEC # 27355)


Iqra University Islamabad (campus).

Personal profile:

Name Tanveer Husain


Father name Ghulam Muhammad
Date of birth 10-Feb-1990
Religion Islam
Nationality Pakistani
Passport No FR6906321
CNIC No. 33104-7352632-5

You might also like