You are on page 1of 2

Product Specifications

2NPX210R
2NPX210R--V1
Argus® Twin Beam Antenna, 1710–2170 MHz, 35° horizontal beamwidth, internal
electrical tilt with manual override. Horizontal Beamwidth at ±31°.
l Integrated Internal Remote Electrical Tilt (RET), with independent control of electrical tilt
with manual override on all arrays

OBSOLETE
This product was discontinued on: December 31, 2015
Replaced By
HBXX-3817TB1-VTM Andrew® Twin Beam Capacity Antenna, 1710–2180 MHz, 2x 38° horizontal beamwidth, RET
HBXX-3817TB1-A2M compatible

Electrical Specifications
Frequency Band, MHz 1710–1920 1920–2170
Gain, dBi 18.2 19.2
Beam Centers, Horizontal, degrees ±31 ±31
Beamwidth, Horizontal, degrees 40 34
Beamwidth, Vertical, degrees 7.6 6.8
Beam Tilt, degrees 0–10 0–10
USLS (First Lobe), dB 18 18
Front-to-Back Ratio at 180°, dB 30 30
Isolation, dB 22 22
VSWR | Return Loss, dB 1.43 | 15.0 1.43 | 15.0
PIM, 3rd Order, 2 x 20 W, dBc -150 -150
Input Power per Port, maximum, watts 300 300
Polarization ±45° ±45°
Impedance 50 ohm 50 ohm

General Specifications
Antenna Brand Argus®
Antenna Type DualPol® twin beam with internal RET
Band Single band
Brand Argus® | DualPol®
Operating Frequency Band 1710 – 2170 MHz
Performance Note Outdoor usage

Mechanical Specifications
Lightning Protection dc Ground
Radome Material Polyester fiberglass pultrusion
RF Connector Interface 7-16 DIN Female
RF Connector Location Bottom
RF Connector Quantity, total 4

©2016 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope. page 1 of 2
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: January 16, 2016 May 27, 2016
Product Specifications
2NPX210R
2NPX210R--V1

Wind Loading, maximum 720.0 N @ 160 km/h


161.9 lbf @ 160 km/h
Wind Speed, maximum 200 km/h | 124 mph

Dimensions
Depth 120.0 mm | 4.7 in
Length 1330.0 mm | 52.4 in
Width 370.0 mm | 14.6 in
Net Weight 18.5 kg | 40.8 lb

Remote Electrical Tilt (RET) Information


Input Voltage 10–30 Vdc
Power Consumption, idle state, maximum 2.0 W
Power Consumption, normal conditions, maximum 13.0 W
Protocol 3GPP/AISG 2.0 (Single RET)
RET Interface 8-pin DIN Male
RET Interface, quantity 1 male

Packed Dimensions
Depth 216.0 mm | 8.5 in
Length 1445.0 mm | 56.9 in
Width 400.0 mm | 15.7 in
Shipping Weight 20.0 kg | 44.1 lb

Regulatory Compliance/Certifications
Agency Classification
RoHS 2011/65/EU
China RoHS SJ/T 11364-2006
ISO 9001:2008

Included Products
T-041-GL-E — Argus® Adjustable Tilt Pipe Mounting Kit for 2.0"-4.5" (50-115mm) OD round members for panel antennas.
Includes 2 clamp sets.

* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance

©2016 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope. page 2 of 2
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: January 16, 2016 May 27, 2016

You might also like