Professional Documents
Culture Documents
2 . 0 Standard
Installations
2.1 Install Ceiling Plate and NOTE: If the installation site has a finished floor, lay down two 4' x 4'
Down Tube (120 x 120 cm) sheets of oil-impregnated hardboard (or a similar
material) to protect flooring surface during procedure.
1. Use a pallet truck or similar machine to position the system package
WARNING – PERSONAL
! INJURY AND/OR PERSONAL
near the ceiling structure where the lighting system will be installed.
• Predetermine monitor arm stop location for desired location in
INJURY HAZARD: Follow
room prior to placing on 4 x 4 blocks.
installation steps in the
sequence described. Failure • Place 4 x 4 wood blocks or equivalent under each corner to
to follow this sequence can allow for Genie Lift clearance.
result in damage to
equipment or personal Important: Allow at least 3’ (1 m) clearance around the crate to
injury. permit lifting device access. Access to crate is necessary for
installing ceiling plate.
2. Remove canopy sidewall box, canopy, ceiling plate, down tube and
all loose miscellaneous items including hardware not affixed to crate
base.
NOTE: It may be useful to temporarily preinstall ceiling plate to ceiling
structure to preset mounting stud nuts to proper height prior to step
4. Support studs in ceiling structure can be left slightly loosened to
allow for easier positioning while lifting ceiling plate to installation
height.
2.2 Install Lighting and 1. Use a pallet jack to position the lighting system below the ceiling
Visualization System mount structure.
2. Ensure lighting system arms are strapped together to prevent
unwanted movement while raising system.
3. Position lifting device(s) to raise system.
4. Loosen brake screws to allow spindle rotation.
5. Raise system so that top of ceiling plate is just below bottom of
mounting studs.
6. Align mounting holes with mounting studs.
NOTE: Verify lock washers and flat washers are properly positioned
on top of ceiling plate prior to raising system.
7. Slowly raise system to ceiling structure being careful not to damage
wiring/cables.
8. Install remaining washers and nuts.
9. Level and tighten to secure.
10. Remove all strapping between lighting system and crate base.
11. Lower crate base.
12. Discard all packing material.
2
129378-513 Installation Instructions Addendum Harmony LC/vLED Surgical Lighting System