Professional Documents
Culture Documents
Model FSV-1 Fail-Safe Valve Trim Component For Model DV-5 Deluge Valve Used in Deluge and Preaction Systems
Model FSV-1 Fail-Safe Valve Trim Component For Model DV-5 Deluge Valve Used in Deluge and Preaction Systems
WARNING Operation
The Model FSV-1 Fail-Safe Valve de-
scribed herein must be installed and
maintained in compliance with this
When the FSV-1 Fail-Safe Valve is in
its closed position (Ref. Figure 1) it Installation
document, as well as with the applica- retains water pressure in the Dia- Refer to the applicable technical data
phragm Chamber of the DV-5 Valve sheets describing the various options
ble standards of the National Fire Pro-
when the DV-5 is set for service. Upon for installing the Model DV-5 Deluge
tection Association, in addition to the
operation of the DV-5 Valve, the piping Valve (i.e., deluge and preaction sys-
standards of any other authorities hav- downstream of the DV-5 Valve be-
ing jurisdiction. Failure to do so may tems utilizing the Model DV-5 Deluge
comes pressurized. The Pilot Cham- Valve).
impair the performance of this de- ber of the FSV-1 is then pressurized
vice. via its trim connection to the down-
The owner is responsible for maintain-
ing their fire protection system and de-
stream side of the DV-5 Valve. Pres-
surization of the Pilot Chamber opens
Setting
vices in proper operating condition.
The installing contractor or sprinkler
the FSV-1 (Ref. Figure 1). After open-
ing of the FSV-1, make-up pressure to
Procedure
manufacturer should be contacted the Diaphragm Chamber of the DV-5 The Model FSV-1 Fail-Safe Valve
with any questions. Valve cannot occur. Even if the releas- automatically resets after the system
ing device that originally released piping downstream of the Model DV-5
water from the Diaphragm Chamber Deluge Valve is drained and returned
were to close, the FSV-1 prevents the to its normal 0 psi gauge pressure.
DV-5 Valve from inadvertently reset-
ting after its initial opening. Upon op-
eration, the FSV-1 will vent the DV-5
Diaphragm Chamber to atmosphere
quicker than it can be repressurized
through the 1/8 inch (3,2 mm) restric-
tion in the diaphragm supply connec-
tion to the DV-5.
5-1/8" DIA.
(130,2 mm)
1/2" NPT ACTUATING PORT 1-3/16" HEX
OPEN TO ATMOSPHERE VIA (30,0 mm)
VALVE TRIM CONNECTED TO
DOWNSTREAM SIDE OF 2
DELUGE VALVE
9
8
2-1/8"
(54,0 mm) 10
5 3-3/8"
(85,7 mm)
11
1/2" NPT OUTLET
PORT OPEN TO
ATMOSPHERE 13 1
1/2" NPT
OUTLET PORT
WATERFLOW FLOW
TO DRAIN PATH
12 OPENED
6
7
1/2" NPT INLET
PORT WATERFLOW 14
FROM DELUGE
VALVE DIAPHRAGM
CHAMBER SUPPLY
ACTUATED CONDITION
© 2008 TYCO FIRE & BUILDING PRODUCTS, 451 North Cannon Avenue, Lansdale, Pennsylvania 19446