Professional Documents
Culture Documents
WARNING: PUT THE SAFETY DEVICES AND THE WARNING NOTICES IN POSITION BEFORE YO
U START A TASK ON OR NEAR:
- THE FLIGHT CONTROLS
- THE FLIGHT CONTROL SURFACES
- THE LANDING GEAR AND THE RELATED DOORS
- COMPONENTS THAT MOVE.
MOVEMENT OF COMPONENTS CAN KILL OR CAUSE INJURY TO PERSONS AND/OR
CAN CAUSE DAMAGE TO THE EQUIPMENT.
WARNING: MAKE SURE THAT THE TRAVEL RANGES OF THE FLIGHT CONTROLS SURFACES ARE
CLEAR. MOVEMENT OF FLIGHT CONTROLS CAN CAUSE INJURY TO PERSONS AND/
OR DAMAGE TO EQUIPMENT.
WARNING: MAKE SURE THAT THE TRAVEL RANGES OF THE FLIGHT CONTROLS SURFACES ARE
CLEAR. MOVEMENT OF FLIGHT CONTROLS CAN CAUSE INJURY TO PERSONS AND/
OR DAMAGE TO EQUIPMENT.
WARNING: YOU MUST PUT ON AND ATTACH A SAFETY HARNESS BEFORE YOU START WORK:
- ON THE THS OR IN THE REAR FUSELAGE
- ON TOP OF THE WINGS OR PYLONS.
WITHOUT A SAFETY HARNESS, YOU CAN FALL. THIS CAN KILL YOU OR CAUSE YOU
INJURY.
CAUTION: DO NOT CAUSE DAMAGE TO THE SURFACES. THE COMPONENTS ARE MADE OF CAR
BONFIBER REINFORCED PLASTIC.
QT
REFERENCE DESIGNATION
Y
No specific AR ACCESS PLATFORM 4M (13 FT)-ADJUSTABLE
No specific AR SAFETY CLIP - CIRCUIT BREAKER
No specific 1 WARNING NOTICE(S)
98D27309009003 2 COLLAR-DEPTH ACTUATOR
98D27309009004 2 COLLAR-DEPTH ACTUATOR
© AIRBUS S.A.S. ALL RIGHTS RESERVED. CONFIDENTIAL AND PROPRIETARY DOCUMENT.
1/8
30/04/2020 GOW - A318 / A319 / A320 / A321 - AMM - 01-Feb-2020 - 11-25-55-910-001-A - Record the weight of the elevator
QT
REFERENCE DESIGNATION
Y
98D27903500000 2 PIN-SIDE STICK LOCKING
B. Referenced Information
REFERENCE DESIGNATION
Ref. 29-10-00-864-001-A Depressurize the Green Hydraulic System
Ref. 29-10-00-864-002-A Depressurize the Yellow Hydraulic System
Ref. 29-10-00-864-003-A Depressurize the Blue Hydraulic System
Ref. 55-13-11-000-001-A Remove/Open of the Trimmable Horizontal Stabilizer (THS)
Trailing-Edge Access-Panels
Ref. 55-13-11-400-001-A Install/Close of the Trimmable Horizontal Stabilizer (THS) T
railing-Edge Access-Panels
Ref. CMM 55-21-15
SUBTASK 11-25-55-941-050-A
D. Safety Precautions
(1) Put the WARNING NOTICE(S) in the flight compartment to tell persons not to operate
the flight controls.
(2) Put the WARNING NOTICE(S) in position to tell persons not to operate the hydraulic s
ystems.
(3) Put the ACCESS PLATFORM 4M (13 FT)-ADJUSTABLE in position at zone 330 for the le
ft hand elevator and/or zone 340 for the right hand elevator.
SUBTASK 11-25-55-020-050-A
E. Access
(1) Remove the THS trailing edge access panels as necessary Ref. AMM TASK 55-13-11-0
00-001.
© AIRBUS S.A.S. ALL RIGHTS RESERVED. CONFIDENTIAL AND PROPRIETARY DOCUMENT.
3/8
30/04/2020 GOW - A318 / A319 / A320 / A321 - AMM - 01-Feb-2020 - 11-25-55-910-001-A - Record the weight of the elevator
(a) there is not a free line to record the new weight of the elevator and/or
(b) elevator is reidentified with a new part number according to Ref. CMM 55-21-1
5.
1 Write a line on the Part Number on the identification plate (2), the first ti
me you replace the weight identification plate (1).
(3) Record the part number and weight on a new weight identification plate (1).
(4) Install the new weight identification plate (1) Ref. CMM 55-21-15.
** ON A/C FSN 001-002, 005-007, 251-300
(a) there is not a free line to record the new weight of the elevator and/or
(b) elevator is reidentified with a new part number according to Ref. CMM 55-21-1
5.
(3) Record the part number and weight on a new weight identification plate (1).
© AIRBUS S.A.S. ALL RIGHTS RESERVED. CONFIDENTIAL AND PROPRIETARY DOCUMENT.
4/8
30/04/2020 GOW - A318 / A319 / A320 / A321 - AMM - 01-Feb-2020 - 11-25-55-910-001-A - Record the weight of the elevator
(4) Install the new weight identification plate (1) Ref. CMM 55-21-15.
SUBTASK 11-25-55-081-050-A
B. Remove Locking Devices
(1) Remove the PIN-SIDE STICK LOCKING (98D27903500000) from the CAPT and F/O si
de stick controllers.
CAUTION: MAKE SURE THAT YOU REMOVE THE "COLLAR-ELEVATOR SERVO CONT
ROL SAFETY" BEFORE YOU PRESSURIZE THE ELEVATOR SERVO CONTR
OL. IF YOU DO NOT REMOVE THE COLLAR, YOU CAN CAUSE DAMAGE T
O THE ELEVATOR SERVO CONTROL.
(2) Remove the COLLAR-DEPTH ACTUATOR (98D27309009003) or COLLAR-DEPTH ACTU
ATOR (98D27309009004) from the servocontrol elevators.
SUBTASK 11-25-55-942-050-A
C. Remove Ground Equipment
(1) Remove the ground support and maintenance equipment, the special and standard to
ols and all other items.
(2) Remove the access platform(s).
(3) Remove the WARNING NOTICE(S).
** ON A/C FSN ALL
SUBTASK 11-25-55-865-051-A
D. Remove the safety clip(s) and the tag(s) and close this(these) circuit breaker(s):
Z345
Z335
A
B
1
N_MM_112555_2_ACM0_01_00
Z345
Z335
A
C
A
B
C 1 B
2
N_MM_112555_2_AAM0_01_00