ranena VIBRATION SEVERITY STANDARO
ROTATING MACHINERY HAVING RIGID ROTORS
Table 1-Vibration Severity Criteria
Recommended for General Machinery Turning from 600 to 12000 RPM
(Based on ISO Is 2372)
RMS Overall velocity Level Vibration Severity Criteria
Measured
in 1000 Hz Bandwidth
Mm/s In/s Cass I Cass Gass Chass V
0.28 0.01
0.45 0.02 Good Good ood God
O71 0.03
112 0,04 5
18. 0.07 Satisfactory satisfactory
28 0.11 Satisfactory
45 0.18 Unsatisfactory | Gnsatisfactory Satisfactory
7a 0.28 Unsatisfactory
iz 0.44 Unsatisfactory
18 ova Unacceptable | Unacceptable
28 FET) Unacceptable | Unacceptable
45 77
Gass L_ Small-sized machines (powered from 0 to 15 KW)
ass I. Medium-sized machines (powered from 15 to 75 KW)
‘ass I. Large-sized machines (powered > 75 KW) mounted on “Rigid Support” structures and foundations
ass IV. Large-sized machines (powered >75 KW) mounted on "Flexible Support” structures
Note:
‘Supports determined as rigid support ifthe fundamental frequency of the machine installed on the support is higher than the machine main
‘exctation frequency
‘Supports determined as flexible support if the fundamental frequency of the machine installed onthe support is lower than the machine main
‘exctation frequency
Table 2-Vibration Severity Criteria
Recommended for Slow Speed Large Mac!
(Based on ISO Is 3945)
ery Turning from 600 to 1200 RPM
RMS Overall Velocity Level Support Gasification
Measured
in 1000 Hz Bandwidth
Mm/s In/sec Rigid Supports Fexible Supports
0.46 0.018
0.74 0.028
112 0,044 Good Good
1.80 0.071
2.80) 0.110 5
4.60 0.180 Satisfactory Satisfactory
7.10 0.280
112 0.440 Unsatisfactory Unsatisfactory
18.0 0.710
28.0 1.100
Unacceptable
46.0 1.800 Unacceptable
71.0 2-800
‘ibratechnica.comivbrationsaventy ml
weranoi2 VIBRATION SEVERITY STANDARO
RMS Velocity amplitude for the following shaft heights, in mm
motor | pn
Gade 80