* STM32 F405 MCU FC w/OSD, integrated MPU6000 accelerometer and gyro;
* Plug-in connection, pin header design, easy to install and disassemble; * Support current meter; * BLHeli-32-bit 35A 4-IN 1 ESC * Compact size 26*26*21mm * Super-lightweight 16.4g (including screws,aluminum column & nuts) * Switchable 0/25/100/200mW 48CH VTX
SucceX mini F4 V2.0 Flight Controller Specs: - MCU: 100MHz STM32F450 - IMU: MPU6000 gyro/accelerometer (SPI) - Integrated LC Filter - Input Voltage: 2-6S Lipo - OSD: BetaFlight OSD w/ AT7456E chip - BEC Output: 5V@3A - Size: 26x26mm board, 20mm mounting holes (M2) - VCP, UART - WS2812 Led Strip: Yes - Beeper: For active 5V buzzer - SBUS input: Yes - Target: OmnibusF4SD - Default firmware: Betaflight V3.5.3 ( V3.5.4 or higher version does not support current meter yet)
SucceX Mini 35A V2.0 2-6S 4 in 1 ESC Specs - MCU:STM32F051 - Current Sensor: Yes - Input:2-6s lipo - Installing Hole: 20x20mm, M2 - Target:iFlight-BL32-4IN1 - Constant:35Amps - Burst:45Amps - Dimensions:31*31mm(including the power pads) - Mounting Holes:20*20mm - Supports Dshot1200,Proshot,Oneshot,Multishot
SucceX Mini V1.0 VTX Specs: - Input voltage: 5-36V DC - Channel: 48 - Power transmission: 0mW(Pit mode) / 25mW / 100mW / 200mW - Size (mm): 24 * 26 mm - Mounting Holes Dimension: 20mm x 20mm - Connector type: IPEX Connector - BEC Output: 5V/1A for Camera of FC - Antenna: IPEX - Traditional button + LED control - IRC Tramp protocol
Package included (Pre-built as stack): - 1 x SucceX mini F4 V2.1 Flight Controller - 1 x SucceX Mini 35A V2.0 2-6S 4 in 1 ES - 1 x Succex Mini V1.0 VTX - Cable Set