Professional Documents
Culture Documents
Robot
Robot
Based on the manual in the kit package, you can make the car all by yourself and then create your
own sketch to realize different movements of the car as you want. To support further exploration, a
sensor shield is used so that there can be more I/Os from the SunFounder Uno, to which more parts
can be connected.
For better experience, a calibration procedure is provided. Before running the car, you need to
calibrate the parts so they can work normally under the ambient environment. After all is
completed, you can then realize the functions like obstacle avoiding, line tracing, and light seeking,
etc.
Component List
1 pack x Acrylic Plates
1 pack x Threaded fasteners
1 x Tower Pro Micro Servo SG90
1 x Tower Pro Micro Servo MG995
2 x Gear Reducer
4 x Wheel
1 x SunFounder UNO R3 board
1 x DC Motor Driver Module
1 x Step-down DC-DC Converter Module
1 x Switch Module
1 x Photoelectric Switch
4 x Photosensitive Module
2 x Obstacle Avoidance Module
5 x Tracking Module
1 x Dual 18650 battery holder
2 x Ribbon (13cm)
1 x USB Data Cable
Serval Dupont Wires
1 x Screwdriver
Self-provided Parts
2 x 18650 Rechargeable Li-ion Battery (3.7V) without protection circuit board