Professional Documents
Culture Documents
WARNING
Do not connect to any external power before disassembly.
The potential for electric shock exists.
Mounting
Back Cover Screws
Battery
Connecting
WARNING
Never attempt to connect or disconnect RF equipment from the transmission line
while RF power is being applied.
Leaking RF energy is a potential health hazard.
Note: Use the appropriate Bird Power sensor for the RF power measurement
application. An attenuator may be required.
USB SERIAL
TRANSMITTER/
GENERATOR OR
DIRECTIONAL POWER SENSOR ANTENNA
USB SERIAL
OR
TERMINATING POWER SENSOR
USB
SERIAL
USB
POWER METER
TO PC
POWER METER PC
USB
SERIAL
Setting Up
1. Connect the sensor.
2. Turn on the DPM.
3. Zero the sensor (WPS and TPS only).
4. Turn on the RF source.
5. Take a reading.
Note: The analog bar graph will respond immediately to changes in
the RF power. The major and minor displays will respond after a delay of
1 to 13 seconds, depending on the power level.
Shutting Down
z Press and Hold the “OK” key for 2 seconds. This will put the unit into Sleep
mode. It will stop loggging in this mode.
z Press and hold the “OK” key until the “OK” key illuminates, approximately 8
seconds. Release the key after it illuminates. This will shut the unit down
completely.