Professional Documents
Culture Documents
a. 0.8 MHz
b. 1.8 MHz
c. 8.1 MHz
d. 1.6 MHz
52. The colors found around the perimeter of the color triangle are said to be
a. Saturated
b. Dark
c. Light
d. Monochrome
53. At what position on the color triangle will saturated yellow be located?
d. At the center
54. What is the phase difference between the I and Q color signal carriers?
a. 0°
b. 45°
c. 60°
d. 90°
55. _____ is the most effective filter for separating luminance and chrominance frequency components.
a. Low pass
b. Band pass
c. Notch
d. Comb
56. The chrominance processing circuits can be deactivated when monochrome broadcasts are received
by the
a. Color killer
b. SAW filter
c. NOT gate
57. What is the standard video level, in percent PEV, for blanking?
a. 25 %
b. 0 %
c. 12.5 %
d. 75 %
58. What is the percent video level, in percent PEV, for black?
a. 0 %
b. 25 %
c. 12.5 %
d. 70 %
59. What is the standard video level, in percent PEV, for white?
a. 0 %
b. 12.5 %
c. 25 %
d. 70 %
60. One should first perform _____ before a convergence setup is performed.
a. Gray tracking
b. Screen setting
c. Alignment
d. Degaussing
61. If there are too many harmonics, one should check the
a. Coupling
b. Tuning of circuits
c. Shielding
d. Any of these
c. Operating class AB
d. All of these
a. Sync separator
b. AFC
c. High voltage
d. AGC
d. All of these
a. On the bridge
66. The alignment of the three color guns to a common point is known as
a. Blooming
b. Confetti
c. Demodulation
d. Convergence
a. Field
b. Frame
c. Cycle
d. Interface set
b. Frame
c. Cycle
d. Interface set
a. 14750
b. 15570
c. 15750
d. 16550
70. Picture frames are repeated at the rate of _____ per second
a. 25
b. 30
c. 40
d. 50
a. AGC
b. High voltage
c. Video signal
d. Television signal
72. The sound and video signals are separated at the _____ of the TV receiver
a. IF stage
b. Video amplifier
c. Video detector
d. Burst separator
73. The presence of color bars is an indication that there is a problem in the _____ circuit
a. Horizontal
b. Reactor
c. Burst separator
d. Chroma amplifier
74. Type of emission produced when a frequency modulated transmitter is modulated by a TV signal
a. A3F
b. F3F
c. A3C
d. F3C
a. RTTY
b. SSB
c. TV
d. Modulated CW
a. Facsimile
b. Modulated CW
c. Television
d. RTTY
a. Pad filter
b. Bad rectifier
b. Color killer
c. Color detector
d. Color oscillator
a. Chrominance
b. Brightness
c. Contrast
d. Luminance
a. Daytime
b. Experimental
c. Nighttime
d. Dawntime
a. Dawntime
b. Nighttime
c. Daytime
d. Experimental
b. Excessive gain
a. CF3
b. C3F
c. B8E
d. A3E
a. TV broadcasting
b. Monaural broadcasting
c. Stereo broadcasting
d. HF point-to-point communications
85. Which of the following filters block FM radio band for TV channels (2 to 13)?
a. High-pass filter
b. Low-pass filter
c. Band pass filter
d. Band-reject filter
b. 30 to 300 kHz
c. 88 to 108 MHz
a. A5C
b. A0
c. A3
d. F3
a. MF
b. HF
c. VHF
d. LF
a. 1902
b. 1945
c. 1947
d. 1952
a. 1904
b. 1945
c. 1953
d. 1960
a. HFC
b. HSC
c. HAFC
d. All of these
92. A measure of how well the receiver can respond to every weak signals/
a. Selectivity
b. Sensitivity
c. Fidelity
d. Quality factor
a. 15 kHz
b. 75 kHz
c. 5 kHz
d. 100 kHz
a. Class A
b. Class B
c. Class C
d. Class D
95. Standard AM broadcasting use _____ for greater and efficient coverage
d. All of these
98. Local oscillator of a broadcast receiver always tunes to a frequency higher than the incoming
frequency in order
d. All of these
99. Type of filter used in TV receivers that separates the chroma signal from the colorplexed video signal
but leaves intact the Y-component
a. Comb filter
b. Bandpass filter
c. Color filter
a. A
b. N
c. H
d. F