TROUBLE DIAGNOSIS
< SERVICE INFORMATION > [YD25DDTi)
Circuit Diagram woe any
Gee ruse I nt
'
use PANES einen 7 1s
-FUSIBLE LINK nor __f I
OE Nez Ie
Pion | LL ym
seus
a
ia
Pah I"
EC55TROUBLE DIAGNOSIS
< SERVICE INFORMATION > tvo2s00T
a cumon syatcr]
og 5
" bs
(Creo neren conmacc unt]
a ol
“te Loe
Sonne Yt Bn
l 25
si
7
sear
7) RRSR
q ae
‘92] oc moron
neg
EC-456TROUBLE DIAGNOSIS
< SERVICE INFORMATION >
ECM Hamess Connector Terminal Layout
[vp25DDTi]
aes
pa
san
ECM Terminal and Reference Value
PREPARATION
1. ECM (1) is located behind the instrument lower panel
2. Remove ECM cover.
3. When disconnecting ECM harness connector, loosen it with
levers as far as they will go as shown in the figure.
4, Connect a break-out box and Y-cable adapter between the ECM
and ECM harness connector.
+ Use extreme care not to touch 2 pins at one time
+ Data is for comparison and may not be exact.
ECM INSPECTION TABLE
Specification data are reference values and are measured between each terminal and ground.
Pulse signal is measured by CONSULT-IIL
EC457