Appendix
1. Noise and vibration data.
2. Emergency stop time and inertial drop distance
of ram
3. Center of gravity of machine
4. Safety data sheets.
4-1, Shell Alvania EP Grease 1, 2, RO, ROO, & ROOO
4-2. Shell Tellus Oil
4-3. THK AFB-LF Grease
4-4. THK AFC Grease.
A-10
A416
AB
At2, Emergency stop time and inertial drop distance of ram
Model Emergency stop time, ms arisen
5020 85 7 {0.28}
Hs8025 85 740.28)
181303 85 740.28)
481703 85 740.28)
Hs2204 85 7 {0.26}
3. Center of gravity of machine
The center of gravity of the machine is shown below.
I
|
ome |
Unit: mm {in.}
Model A B pera E
HS5020 1155 {45.5} | 395 {15.6} 90 {3.5} | 635 (32.9) 35 {1.4}
Hs8025 | 1140 (44.9) | 340 (13.4) | 90(3.5} | 1060(41.7}| 401.6)
Hs1303__| 1250 449.2}| 385 (15.2) | 100439) | 1330(52.4}| 3541.4)
Hs1703__| 1190 146.9} | 350(13.8) | 115 (4.5) | 1385 (54.5}| 251.0}
Hs2204 | 1140 444.9) | 310 (12.2) | 16046.) | 1955 (7.0}| 1540.6)First Aid - inhalation:
First Aid - Skin:
First Aid - Eye:
First Aid - Ingestion:
Advice to physicians
SHELL ALVANIA EP GREASE 1, 2, R0,RO0, & ROOD
Inhalation of any vapours from this product isnot likely to present
an acute hazard,
lemove contaminated clothing and wash affected skin with soap
and water. If persistent initation occurs, obtain medical attention,
It high pressure injection injuries occur, obtain medical attention
immediately.
Flush eye with copious quantities of water. If persistent irtation
‘occurs, obtain medical attention.
Wash out mouth with water and obtain medical attention. DO
NOT INDUCE VOMITING.
Treat symptomatically. Aspiration into the lungs may result in
‘chemical pneumonitis. Dermatitis may result from prolonged or
repeated exposure.
5. FIRE FIGHTING MEASURES
Specific hazards: ‘Combustion is tkely to give rise to a complex mixture of gases
‘and airbome particulates, including carbon monoxide, oxides of
‘sulphur, and unidentified organic and inorganic compounds.
Extinguishing medi Foam and dry chemical powder Carbon dioxide, sand or earth
‘may be used for small res only
Unsuitable extinguishing Water in a jet. Use of Halon extinguishers should be avoided for
media: ‘environmental reasons.
Protective equipment: Proper protective equipment including breathing apparatus must
‘be wom when approaching a fre in a confined space.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions:
Personal protection:
Environmental
precautions:
Clean-up methods - sm:
spillage
Clean-up methods - large
spillage:
‘Avoid contact with skin and eyes.
‘Wear impermeable gloves and boots.
Prevent trom entering into drains, ctches or rivers. Inform local
authorties if this cannot be prevented.
‘Shovel into suitable, clearly marked container for disposal or
reclamation in accordance with local reguiations.
As for small spi.
HANDLING AND STORAGE
Handling:
Storage:
Storage temperature:
handing product in cums, salt fotwedr shod be wom
‘re proper barcng eqapmar should be usd: Paeent
Spiages
Keepin a cool, ey, wel-vertiatd place. Use ropa abeed
tre loeable containers, Avid rot surg heat ore, aed
tong oxting agents
(°C minimum to 50°C maximum.‘SHELL ALVANIA EP GREASE 1, 2, R0,R00, & ROOO
11. TOXICOLOGICAL INFORMATION
Basis for assessment:
Acute toxicity - oral:
Acute toxicity - dermal
Respiratory irritation:
Skin sensitization:
Carcinogenicity:
Mutagenicity:
Other information:
‘Toxicological data have not been determined specificaly for this
Product. Information given is based on a knowledge of the
‘components and the toxicology of similar products,
|LDg9 expected to be above 2000 mg/kg
LD gq expected to be above 2000 mg/kg
Expected to be slightly initant.
Expected to be slightly initant.
Ht vapours are inhaled, slight intation ofthe respiratory tract may
‘occur.
Not expected to be a skin sensitizer.
Product is based on mineral oils of types shown to be
rnon-carcinogenic in animal skin-painting studies.
Not considered to be a mutagenic hazard
Prolonged and/or repeated contact with products containing
‘mineral ols can result in defatting ofthe skin, particularly at
clevated temperatures. This can lead to iitation and possibly
dermatitis, especially under conditions of poor personal hygiene.
‘Skin contact should be minimised.
Used grease may contain harmtul impurities that have
accumulated during use.The concentration of such harmful
impurities will depend on use and they may present risks 10
health and the environment on disposal. ALL used grease should
be handled with caution and skin contact avoided as far as
possible.
12. ECOLOGICAL INFORMATION
Basis for assessment:
Mobility:
Persistence/degradability:
Bioaccumulation:
Ecotoxicity:
Ecotoxicological data have not been determined specifically for
this product. Information given is based on a knowledge of the
Components and the ecotoxicology of similar products.
‘Semi-sold under most environmental conditions. Floats on
water. If it comes into contact with sol, t will strongly adsorb to
‘oi panicles.
Not realy biodegradable. Major constituents are expected to be
inhorently biodegradable, but the product contains components,
Poorly soluble mixture. Product is expected to be practically
non-toxic to aquatic organisms, LC/ECsq > 100 mg/L. May
‘cause physical fouling of aquatic organisms.
(LC/ECg0 expressed as the nominal amount of product required
to prepare aqueous test extract)
13. DISPOSAL CONSIDERATIONS
Waste disposal:
Used or waste grease should be recycied or disposed of inSHELL ALVANIA EF GHEASE 1, 2, HU,HUU, & HUOO
TABLE 1: ALVANIA EP GREASES
‘Typical properties
‘SHELL ALVANIA 7 2 RO ROO R000
EP GREASE
GRADE
Density at 15°C 300 300 300 300 300
(kg/m)
Dropping point >180 >180 SITS Not
°C Applicable
(by ASTM D-566)
“Appearance Brown | Brown | Brown | Brown | BrownSHELL TELLUS OIL
4.
FIRST AID MEASURES
‘Symptoms and effects:
First Aid - Inhalation:
First Aid - Skin:
First Aid - Eye:
First Aid - Ingestion:
Advice to physicians:
Not expected to give rise to an acute hazard under normal
Conditions of use,
In the unlikely event of dizziness or nausea, remove casualty 10
fresh air. If symptoms persist, obtain medical attention.
Remove contaminated clothing and wash affected skin with
‘soap and water. If persistent tation occurs, obtain medical
attention.
It high pressure injection injuries occur, obtain medical attention
immediately
Flush eye with copious quantities of water. If persistent initation
‘occurs, obtain medical attention.
Wash out mouth with water and obtain medical attention. DO
NOT INDUCE VOMITING.
‘Treat symptomatcally. Aspiration into the lungs may result in
‘chemical pneumonitis. Dermatitis may result from prolonged or
repeated exposure.
FIRE FIGHTING MEASURES
Specific hazards:
Extinguishing medi
Unsuitable extinguishing
media:
Protective equipment:
‘Combustion is likely to give rise to 2 complex moure of airborne
‘Solid and liquid particulates and gases, including carbon
‘monoxide, oxides of sulphur, and unidentified organic and
inorganic compounds.
Foam and dry chemical powder. Carbon dioxide, sand or earth
‘may be used for small fires only.
Water in a jet. Use of Halon extinguishers should be avoided for
‘environmental reasons.
Proper protective equipment including breathing apparatus must
'be worn when approaching a fire in a confined space.
ACCIDENTAL RELEASE MEASURES
Personal precautions:
Personal protection:
Environmental
precautions:
Clean-up methods - small
spillage:
‘Avoid contact with: skin and eyes.
‘Wear impermeable gloves and boots.
Prevent from spreading or entering into drains, ditches or rivers
by using sand, earth, o other appropriate barriers. Inform local
‘authorities if this cannot be prevented
‘Absorb liquid with sand or earth. Sweep up and remove to &
suitable, clearly marked container for disposal in accordance
with local regulations
Prevent from spreading by making 2 barrier with sand, earth or
other containment material. Reciaim liquid directly or in an
absorbent Dispose of as for small spils.
AttPour point:
Flash point:
Flammability limit - lower:
SHELL TELLUS om
‘see Table 1
‘See Table 1
1% VN (typical)
Flammability limit - upper: 10% VIV (ypical)
‘Auto-ignition temperature: > 320°C (typical)
‘Solubility in water: Negligible.
10. STABILITYIREACTIVITY
‘Stability: ‘Stable
Conditions to avoid: Extremes of temperature and direct sunlight.
Materials to avoid: Strong oxidizing agents
Hazardous decomposition Hazardous decompostion products are not expected 10 form
products: during norma storage
41, TOXICOLOGICAL INFORMATION
Basis for assessment:
Acute toxicity - oral:
‘Acute toxicity - dermal:
Acute toxicity - inhalation:
Eye irritation:
Skin irritation:
Respiratory irritation:
‘Skin sensitization:
Carcinogenicity:
Mutagenicity:
Other information:
“Toxicological data have not been determined specifically for this
product Information given is based on a knowledge of the
Components and the toxicology of similar products.
[LDgo expected to be above 2000 mg/kg
LD expected to be above 2000 mg/kg
Data not available
Expected to be slightly intant
Expected to be slightly tant
I mists are inhaled, sight intation ofthe respiratory tract may
occur.
Not expected to be a skin sensitizer
Products based on minera ots of types shown to be
rnon-carcinogenic in animal skan-panting studies. Other
‘components are not known to be associated with carcinogenic
Not considered to be a mutagen hazard
Prolonged andlor repeatec contact with this product can resi
defatting of the skin. pariculary at elevated temperatures. This
‘can lead to irtaton anc possibly cematts, especialy under
‘conditions of poor personal mygene Skin contact should be
Used ois may contan narmu cmourtes hat have accumutated
during use The concentration of such impurities wil depend om
Use and they may present "sks t health and the envronmert
fon disposal ALL used oi should be handied with cauon and
‘kin contact avoded as fr 2s possible
A-13‘SHELL TELLUS OIL
16. OTHER INFORMATION
Uses and restrictions: For hydraulic applications requiring a mild ant-weet oil
Technical contact poi ‘Technical Support Team , Lubricants & Bitumen Division
Technical contact number:
sphon 03.5531-5768
Telex: 422373
Fa 03-5531-5768
‘This information is based on our current knowledge and is intended to describe the product fr the purposes
of health, safety and environmental requirements only. It should not be construed as guaranteeing any
specific property of the product.
TABLE 1: SHELL TELLUS OIL
‘SHELL TELLUS OIL 2 2 «6 EI 8 | 100
Density, kgim? at 15°C ees | e70 | a75 | a7e | ea | sea
Pour point, °C 325] 250] .a25| -a25| 225] 275
Flash point, °C (COC) 2oa_| 232 | 240 | 250 | 254 | 268
AASTHK AFB-LF Grease
No.1090-T12174
‘SECTION 8, EXPOSURE CONTROL / PERSONAL PROTECTION
EXPOSURE: “Te infor mineral as TWA Spi a ol mst by ACSIA
ENGINEERING MEASURES. ‘Dora useinareas wiht adecuste vention.
EYE PROTECTION tn
cee
Wea racive eepesseso chica! ey erate
HAND, SKIN AND BODY PROTECTION: When wrourgnd or Femsonty pastes cna cod outr Ua Seacnve
‘oti suc as buy ber mperous os aaa
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
"APPEARANCE AND ODOR: “Tan calor, butter: Bo, mid odor
DENSITY (fen) at 130° owt 0.80
‘SOLUBILITY IN WATER: Neginte
MELTING PONT C. NA
DROPPING PONT ‘3
BOLING POW: [NA (Not appt (High)
‘SECTION 10, STABILITY AND REACTIVITY
“STORAGE STABILITY: ‘This product lable under normal storage
INCOMPATIBIITY:
‘Stong oxdiang agents
DECOMPOSITION PRODUCTS: Garbonoxdos,Sufur oxides, Phosphorous compounds, Zinc oxdas, oe
Wi nt oc
FLASH POINT (METHOD USED) C: 188\Seta Close Cun)
‘SECTION 11, TOXICOLOGICAL INFORMATION
"ACUTE TOXICITY: halon No data a product
Ort No data a product
CORROSIVE AND IRRITANT PROPERTIES: Iprlonged or ropeated shin contact occurs, may cause sin ation.
Wye contact oocur, may cause ye rtaton
‘SECTION 12. ECOLOGICAL INFORMATION
No brow easton ata
‘SECTION 13, DISPOSAL CONSIDERATION
Warte musi be daposed of accordance wih federal, dale and ical endronmen! conta vepuaions
‘SECTION 14, TRANSPORT INFORMATION|
‘Koop away Yom ondaing nator and source of gnion
“isp Be Proecion Law Rested irate substance (Shite: Kanen but table okt)
int Recommandatons on he Transport of Dengrcus Goods: Non dangerous substance
Fotow at regulators in your county
“SECTION 15, REGULATION INFORMATION
Foto l equations im you county
‘SECTION 16. OTHER INFORMATION
REFERENCES:
{)IARC MONOGRAPHS ON THE EVALUATION OF THE CARCINOGENIC RISK OF CHEMICALS TO HUMANS VOLUME 99,
2} Material Saety Data Sheet guidebook (English) (Japan Chemical insusry Associaton iormation Cente)
“Tis Mater! Sat Data Sheet was prepared onthe base of materials iformation, and ata caine
{present by our company. To the best of our owadge, be infomation contained her nis accurate
Final determinaton of stably of al materalis the sol responsi of he usr
‘Alaris may present unknown hazards and shoud be used in can.
‘The infomation bere is ven in good ah, but ne waranty, express or imple, mace.
Copyright THK CO.LTD 2008. Alrights reserved. 2/2
AATTHK AFC Grease
No.1030-T12176
‘SECTION 8. EXPOSURE CONTROL / PERSONAL PROTECTION
Stonct asin
ING MEASURES: ‘Do nc us areas wihout ae veaion
Eve prorecrion Cr cherie sft gpa 8 mst geet
FAND, SKIN AND BODY PROTECTION: When praorgad Cf) feud cates ents sas Soe Sees
obing sch as but ssbo,mpancous te rata
‘SECTION 8, PHYSICAL AND CHEMICAL PROPERTIES
"ABPEARANCE AND ODOR Brown color, Bur Bo, mal or
Stoaes in waren Neciotie
ue
MELTING PONT ne
DROPPING PONT ‘ove 200
BOuNG Po No opel) in)
‘SECTION 10. STABILITY AND REACTIVITY
‘STORAGE STABLITY: This product sale under roma! Borage
INCOMPATIBILITY: ‘Song onding agents,
DECOMPOSITION PRODUCTS: Carbon oxide, Sur oxides, Phophorous compounds te
POLYMERIZATION: Wit nt occur
FLASH POINT (METHOD USED) €: 201(Seta se Cup)
‘SECTION 11. TOXICOLOGICAL INFORMATION
"ACUTE TOXICITY: Inblaion Ne gaa os poss
Ora ata as prose
‘CORROSIVE AND IRRITANT PROPERTIES: Wronget reid sin otc ony en ton
eye contact occurs, may cause oye rastsn
‘SECTION 12, ECOLOGICAL INFORMATION
Ne known esi! dla
‘SECTION 13, DISPOSAL CONSIDERATION
Waste musi be deposed of naccordace with federal sat and iocal eweanment canrlrequnions|
‘SECTION 14, TRANSPORT INFORMATION
"ac aay fon cng maria rd suse onon|
Ut Reconmendatone cre Tenapot of Cangeoce Goode: Non ange substance
Flow al roguations in your cour.
‘SECTION 15, REGULATION INFORMATION
Flow al epuations in your county,
SECTION 16. OTHER INFORMATION
REFERENCES:
{)IARC MONOGRAPHS ON THE EVALUATION OF THE CARCINOGENIC RISK OF CHEMICALS TO HUMANS VOLUME 33
2) Mata! Safty Data Sheet guidebook (Engish) Japan Chemical ndusty Assonaton itormaton Corser)
‘This Material Safety Osta Sheet was prepared onthe bass of materia ntrmaton. and data obtained
st presen by ou company. To the bes of cr knowledge, te nfomation contained here ns accurate
Final determination of sutabity of al mater i the sole responsi of user
[A matenals may poser unkown havards and shou be sed caution |
‘Tha information herein is given in good fath, but no warranty express or mig is mae
Copyright THK CO. TD.2006. Allrights reserved. 272
A-19AMADA CO., LTD.
200, Ishida, Isehara-shi, Kanagawa 259-1196, JAPAN
Printed on recycied paper.2 ev consi or augue 10 2am oaecienec
cocoate ogeeTHK AFC Grease
No.1030-T12176
MATERIAL SAFETY DATA SHEET
Note: Read and understand Material Safety Data Sheet bofors handing or disposing of product
‘SECTION 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
mane ee om,
Tercera: Heese
i Siesta rome te
Beemer nets
Bere Tenner BEES
Stace ee
‘SECTION 2, COMPOSITION / INFORMATION ON INGREDIENTS
MOXTURE: Base ol. Pickens and adaves
INGREDIENTS AND COMPONENTS (% by mass)
‘Sy ibicats
sppr0x. 75
‘Urea ckener Soper 10
Addives (Rust proventves, EP agent otc) approx 15.
LUN CLASS ANO UN NUMBER:
‘SECTION 3, HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW.
‘Prolnged or repeats contact with skin may cause ination.
Sratowed
Nny caine voor ares
Polenta neat tect.
5 eye contact ocr, may cause oye tation
Ske Hprlonge or rpesied en contac ocr, may cause shin tan.
Ingeston: Nay cau vor dares,
SECTION 4. FIRST AID MEASURES
EVE CONTACT: Ganty sine the afte ayes with oan wero aoa TS ios and const
an opthamogat
‘SKIN CONTACT: Wash the affected area under runing water using a mild soap.
INHALATION: Remove the vicim tom the contaminason moat 1 ah
Calta tysianf symptom pers
INGESTION: Do not duce vomsing. Cala physician.
‘SECTION 5. FIRE FIGHTING MEASURES
EXTINGUISH MEDIA ‘iy chemical, Foam, Garton Donde
FIRE FIGHTING PROCEDURE: Fie-ighers should wear sel-contaned bresting apparatis wit fu face pce
‘operated n postive pressure move
‘SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTIONT. HANDLING AND STORAGE
HANDLING: fod dec cv wh kn Fe
Shouts fot Spy sou’ end wren daa of direct sunight
STORAGE: Shou jou
Kooy awe fom sources oat open tas sh spt
‘ed long Sore bes arse pos dg wth age
Copyright THK CO.LTD.2006. Aliights reserved. 1/2
A-18THK AFB-LF Grease
No.1030-T12174
MATERIAL SAFETY DATA SHEET
"Note: Read and understand Material Safty Data Sheet before handing or disposing of product
‘SECTION 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME: THK AFB-UF Grease
PRODUCT TYPE Lustig
MANUEACTURERS NAME: iakeo ti.
ADDR 3.416 Nist-Gotand, Shinagawa, Toyo.
TELEPHONE NUMBER: da.srascazes peer
EMERGENCY TELEPHONE NUMBER,
DATE PREPARED: Mar32006
‘SECTION 2. COMPOSITION / INFORMATION ON INGREDIENTS
MIXTURE: Base ol. hickener and adatives
INGREDIENTS AND COMPONENTS (by mass}
‘Base ol (High retned petcteu of)
‘Thickane (cum soap)
‘asives (EP agent, 2)
LUN CLASS AND UN NUMBER:
SECTION 3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
rlonged or repeated contact wih skin may cause ration.
May cause worm ot artes f Salou.”
Pett nat tet
1 oye contac ocus, may cause eye itaton
Stn I plrged roped cont cons nay cae sin iran
Ingestion: Nay cause verter artes
SECTION 4. FIRST AID MEASURES
EYE CONTAGT: Gently rinse the affected ayes wih dean water for atleast 15 wines we conaut
SKIN CONTACT: Wash te afected area under naning water sing a mid soap.
INHALATION” "Remove the vic om the cortaminaon mmedatly esha
Calla physclan& symptom persist,
INGESTION: Do notice vomiing Cals physisan
‘SECTIONS. FIRE FIGHTING MEASURES
EXTINGUISH MEDI ‘ry chemical, Foam, Caton Donde
FIRE FIGHTING PROCEDURE: Fe-Aghers shoud wea sel-cortatned breathing apparatus wih fl face piece
‘operated in postive pressure mode
‘SECTION 6. ACCIDENTAL RELEASE MEASURES
‘Shu of al sources of gion Absorb spl wid inert materials (ag cy sand or ear then pace
' Chemical waste container wit covers for eponal using nonsparng cos,
‘SECTION. HANDLING AND STORAGE
STORAGE: ‘Should be kent iit sealed and stored in dors out of drect stig.
Keep away tor sources of at open flames and part,
Avoid ong storage prods since he product Cogrades wih age.
Copyright THK CO.,LTD 2006. Al nights reserved. 1/2
A16‘SHELL TELLUS OIL
12, ECOLOGICAL INFORMATION
Basis for assessment:
Mobility:
Persistence/degradability:
Bioaccumulation:
Ecotoxicity:
Ecotoxicological data have not been determined specifically for
this product. Information given is based on a knowiedge of the
‘components and the ecotoxicology of similar producis,
guid under most environmental conditions. Floats on water. it
‘enters sol, it wil adsorb to sol particles and will nt be mobile
Not readily biodegradable. Major constituents are expected to be
inherently biodegradable, but the product contains components
that may persist inthe environment.
Has the potential to bioaccumulate.
Poorly soluble mixture, Product is expected to be practically
‘non-toxic to aquatic organisms, LC/ECs > 100 mg/L. May
Cause physical fouling of aquatic organisms.
(LCIECg9 expressed as the nominal amount of product required
to prepare aqueous test extract)
13. DISPOSAL CONSIDERATIONS
Waste disposal:
Product disposal:
Container disposal
Recycle or dispose of in accordance with prevailing regulations,
Preferably to a recognised collector or contractor The
‘Competence of the contractor to deal satistactorty with this type
of product should be established beforehand
200 tre drums should be emptied and retuned to the supplier
‘or sent to a drum reconditioner without removing or defacing
markings or labels.
Non-reusable small metal and plastic containers should be
recycled where possible, or disposed of as domestic refuse,
14. TRANSPORT INFORMATION
Not dangerous for conveyance under UN,
IMO, ADRIRID and IATA/ICAO codes.
15. REGULATORY INFORMATION
EC Classificatio
EINECS (EC):
TSCA (USA):
MITIJAPAN):
A-14
Not classified as Dangerous under EC enteria
‘All components listed or polymer exempt.
All components listed.
‘All components listed.SHELL reve wn
7. HANDLING AND STORAGE
Handling:
Storage:
‘Storage temperature:
Recommended materials:
Unsuitable materials:
Other information:
When handling product in drums, safety footwear should be
wom and proper handling equipment should be used. Prevent
spilages.
Keep in a cool, dry, well-ventilated place. Use propery labelled
‘and closable containers. Avoid direct sunlight, heat sources, and
strong oxidizing agents,
‘0*C minimum to 60°C maximum
For containers or container linings, use: mild steel or high
density polyethylene.
For containers or container linings, avoid: PVC.
Polyethylene containers should not be exposed to high
temperatures because of possible risk of distortion
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering control
measures:
Occupational exposure
standards:
‘Component name
il mist, mineral
Hygiene measures:
Respiratory protection:
Hand protection:
Eye protection:
Body protection:
Use local exhaust ventilation if there is a risk of inhalation of
vapours, mists or aerosols,
‘Threshold limit values are given below. Lower exposure limits
‘may appiy locally
Limittype Value Unit. ~——Other information
BhourTWA 5 mgim3 ACGIH
15min STEL 10 mgim3 ACGIH
Wash hands before eating, drinking, smoking and using the
toilet.
Not normally required. If ll mist cannot be controlled, 2
respirator fied with an organic vapour cartridge combined with
‘@ particulate pre-fiter should be used,
PVC or nitle rubber gloves.
Wear safety glasses or full face shield if splashes are likely to
occur.
Minimise all forms of skin contact. Wear overalls to minimise
‘contamination of personal clothing. Launder overalls and
Undergarments regulary
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state:
Colour
Odour:
Initial boiling point:
Vapour pressu
Density:
Vapour density (air=1):
Al2
Liquid at ambient temperature.
Light brown
Characteristic mineral oil
>280°C
<0.5 Pa at 20°C
See Table 1
> 1 at20°Safety Data Sheet
Issued: March 24, 2004
SHELL TELLUS OIL
1, IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY
Product name: ‘SHELL TELLUS OIL
Product type: Hydraulic ot
Supplier: ‘Showa Shell Sekiyu KK.
Address: Daiba Frontier Building.3-2,Daiva 2 Chome,
Minato-ku, Tokyo 135,JAPAN
Contact numbers:
Telephone: 03-6531-5766
Te 422373,
Fe 03-5531-8768
Emergency telephone number:
‘Showa Shell Sekiyu K.K. _03-5531-5768,
COMPOSITION/INFORMATION ON INGREDIENTS
Preparation description: Blend of highly-refined mineral ols and additives.
Composition: Highty-refined mineral oils >o7We%
Additives <3mt%
Dangerous On the basis of available information, the components of this
componentsiconstituents: preparation are not expected to impart hazardous properties to
this product,
3. HAZARDS IDENTIFICATION
Human health hazards: "No specific hazards under normal use conditions. Contains
‘mineral ol for which an exposure limit for oll mist applies.
Prolonged or repeated exposure may give rise to dermatitis,
Used oi! may contain harmful impurities
Safety hazards: Not classified as flammable, but will burn.
Environmental hazards: _Not readily biodegradable. Expected to have a high potential to
bioaccumulate
Other information: Not classiied as dangerous for supply or conveyance
A-10Product disposal:
Container disposal:
SHELL ALVANIA EP GREASE 1, 2, RO,ROO, & ROOD
‘accordance with prevailing regulations, preferably to a
Fecagnised collector or contractor. The competence of the
‘contractor to deal satisfactorily with used grease should be
‘established beforehand. Used or waste grease should not be
‘allowed to contaminate sol or water.
As for waste disposal
200 litre drums should be emptied and returned to the supplier or
Sent to a drum reconditioner without removing or defacing
‘markings or labels. Non-reusable small metal and plastic
‘containers should be recycled where possible, or disposed of as
domestic retuso,
14, TRANSPORT INFORMATION
Not dangerous for conveyance under UN, IMO, ADR/RID and IATAVICAO codes.
15, REGULATORY INFORMATION
EC Classification:
EINECS (EC):
TSCA (USA):
METI(JAPAN):
"Not classified as Dangerous under EC erteria,
‘Al components ised or polymer exempt
‘All components listed.
‘Alcomponents listed
16. OTHER INFORMATION
Technical contact point:
Technical contact number:
Telephone:
Fax:
‘Technical Support Team , Lubricants & Bitumen Division
09-5591.5766
(03-8531-5768
This information is based on our current ki
of health, safety and environmental requi
‘specific property ofthe product.
AB
snowiedge and is intended to describe the product fr the purposes
irements only. It should not be construed as guaranteeing anyRecommended materi
Unsuitable materials:
Other information:
‘SHELL ALVANIA EP GREASE 1, 2, RO,R00, & ROOO
Use mild steel or high density polyethylene (HOPE) for
‘containers or container linings.
‘Avoid PVC for containers or container linings.
Polyethylene containers should not be exposed to high
temperatures because of possible risk of distortion.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION.
Occupational exposure None estabished.
standards:
Hygiene measures: Wash hands before eating and drinking.
Respiratory protection: Not normaly roqured.
Hand protection: PVC or nitrile rubber gloves.
Eye protection: Woar safety glasses or full face shield i splashes are ikaly to
oveur
Body protection: Minimise all forms of skin contact. Wear overalls to minimise
Contamination of personal cothing. Launder overalls and
Undergarments regulary
9. PHYSICAL AND CHEMICAL PROPERTIES:
Vapour pressure:
Density:
Vapour density (ai
Dropping point:
Flash point:
Flammability limit - lower:
Flammability limit - upper:
‘Semi-solid at ambient tamperature
‘See Table 1
Characteristic mineral oil
<0.5 Pa at 20°C (based on mineral ol)
See Table 1
>t
‘Soe Table 1
> 200°C (SETA) (based on mineral oi)
1% VV (typical) (based on mineral oi)
10% VV (typical) (based on mineral oi)
Auto-ignition temperature: — > 320°C (typical)
Solubility in water: Negligible
10. STABILITY/REACTIVITY
Stability: ‘Stable
Conditions to avoid: Extremes of temperature and direct sunlight.
Materials to avoid: Strong ovcizing agents
AG
Hazardous decomposition
products:
Hazardous decomposition products are not expected to form
‘during normal storage.Safety Data Sheet
Issued: March 11, 2008
SHELL ALVANIA EP GREASE 1, 2, RO,ROO, & ROOO
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY.
Product name: SHELL ALVANIA EP GREASE 1
SHELL ALVANIA EP GREASE 2
‘SHELL ALVANIA EP GREASE RO
SHELL ALVANIA EP GREASE Roo
‘SHELL ALVANIA EP GREASE ROOO
Product type: Lubricating greases:
‘Supplier: ‘Showa Shell Sekiyu KK.
Address: Daiba Frontier Building.3-2,Daiba 2 Chome,
Minato-ku, Tokyo 195,JAPAN
Contact numbers:
Telephone: 03-5591.5766
Fax: 03-5531-5768
Emergency telephone number:
Showa Shell Sekiyu K.K. _09-5531-5766
2. COMPOSITION/INFORMATION ON INGREDIENTS
Preparation description: A lubricating grease containing highly-efined mineral ols , a
lithium soap thickener, and aditives,
Dangerous (On the basis of available information, the components of this
Componentsiconstituents: preparation are nt expected o impart hazardous properties
{o this product.
3. HAZARDS IDENTIFICATION
Human health hazard:
'No specific hazards under normal use conditions. Prolonged or
repeated exposure may give rise to dermatitis. Used grease may
Contain harmful impurities.
Safety hazard: Not classified as flammable, but will burn.
Environmental hazards: Not readily biodegradable. Expected to have a high potential to
bioaccumulate,
Other information: Not classified as dangerous for supply or conveyance.
4, FIRST AID MEASURES
Symptoms and effects: Not expected to give rise to an acute hazard under normal
conditions of use.
A41. Noise and vibration data
Noise and vibration measurement points
Noise and vibration were measured at 1 m {3.28 ft} apart from the front, rear, and
right of the machine as shown below. The noise measi
{5.25 ft} above ground.
@
1m {3.28 R}
1m (3288)
urement height was 1.6 m
FRONT OF
MACHINE 1mia2en
Noise range A, dB Vibration, dB
Model T
® 2 ® ® @ ®
85020 7o9 | 827 | 784 | 594 | 634 | 546
Hs8025 807 | 829 | 816 | 531 | 572 | 504
HS1303 824 | 828 | 826 | 593 | so9 | sae
HS1703 804 | 849 | 787 | 518 | 500 | S07
Hs2204 743 | 81.0 | 755 | 57.1 | 581 | 619
A?