Professional Documents
Culture Documents
Flow D
Flow D
and the three glass tank with 5 liters each. Cooling of water will begin once the
chiller is started up into a set and varied temperature. For Reverse and Direct
closed to operate in desired arrangement. When a the chiller reached the set
temperature, the water heater will be turn on into same temperature in every
tank indicating that the experiment will be on same load set up or turn on the
water heater into varying temperature indicating that the experiment will be on
varying load set up. When desired load water temperature reached, remain it
turning on the heater thermostat. Start the water up once the pump has been
checked and running in good condition. In same load set-up, adjust the globe
valves into same flow rate each in the flow meter. In varying load set-up, adjust
the flow meter into a flow rate computed using the ratio and proportion of
temperature and flow rate. Record the load water temperature entering and
leaving the evaporator. The experiment will be repeated with new set-up
conditions.