Professional Documents
Culture Documents
Gas Line Water Main Breaker Box Water Valve
Checking Oil Changing tire Jumping Battery
How to Jump a Battery
1. Park car with the dead battery next to the car used to
jump the battery
2. Turn off both cars
3. Clamp one end of the positive cable to the dead
batteries positive clamp
4. Connect the other end of that cable to the other
battery’s positive clamp
5. Connect one end of the negative jumper cable to the
negative terminal of the good battery
6. Connect the other end of the negative cable to
another metal surface away from the battery on the
vehicle with the dead battery (do not touch the two
ends of the cable together while doing this)
7. Start the jumper car’s engine
8. Wait 2-3 minutes and then start the dead car
9. Disconnect the cables in reverse order of how you
connected them
10. Keep the jumped car running for 30 minutes to
recharge the battery
How to change a tire
1. Park car on a flat surface, put on the emergency
brake and hazard lights
2. Remove the hubcap and loosen the lug nuts with a lug
wrench (do not take them off yet)
3. Place a jack underneath the car at a sturdy part of
the frame. Turn the crank at the end of the jack by
hand until it contacts the frame.
4. Add the jack handle for leverage and cranck the
handle until the wheel is high enough to remove the
tire.
5. Remove the lug nuts from the wheel by turning them
counterclockwise (keep them in the hubcap to
prevent them from rolling away). Remove the flat
tire and lay it flat.
6. Line up the spare tire with the wheel studs and place
it on the car.
7. When the wheel is one,replace teh lug nuts and
tighten them by handat first, then with lug wrench
until firm resistance
8. Lower the jack until the wheel is on the ground
9. Tighten lug nuts all the way
10. Drive slowly until the spare tire is replaced