eae
B) FUJIFILM
Optical Section of Laser Printer/Paper Processor LP1500SC/LP2000SC
Procedure for Removing Cushioning Material (Used for Transport)
Cushioning material used to protect the unit during transport is located at the places indicated below.
Remove this cushioning material before using the unit.
Remove the four screws from the optical section's duct
|. View from exit side of the exposure section (A) | cover and remove the cover. Remove the bracket that se-
ccures the optical section during transport. Then reattach
the duct cover. Remove the
cushioning
material
‘Cut and remove the
cord tie. Remove the rubber cushioning
‘material between the optical
frame and the bracket
‘Cut and remove the
cord tie.
‘Cut the cord tie and remove the rubber cushion-
ing material.
‘Remove the polystyrene-foam cushion-
ing material
3. Cushioning material at the rear (after
2. Cushioning material at the front (after lifting lifting up the left-side top cover) (C)
up the left-side top cov
he «top cover) (B) Remove the polysiyrene-foam cushioning material (wo
pieces)
Cut the cord tie and re-
move the rubber eushion- | FRemove the rubber cushioning
material.
4, Rear side (opposite the operation panel) (D) | Remove the cushion-
jing material
Positions indicated in the above photographs (ustionng materi rinsed by the dark places)
ex
‘Photograph
A
yw ease) Cr)
: Photograph \ ‘Opeation aes)
a me
Photograph
c
RetNoPPoS154€ TO-$05-FGIHE)