Service Parts so
Topics ‘May, 1990
sora
meme aaron
4 Lio/NT
eae
‘Camtollower Socket Identification
we age Sap tao corey Fin ooa oer
H/B 3370347 /3810395 04.01
With the introduction of the 91 L10, and the 91 N14 model engines, also comes a change in the camfoliower socket
Used on these engines. This topic will distinguish the changes from present production engines, and identify which
socket must be used with each engine.
Refer to the L10 Shop Manual, Bulletin No. 3379347, and the NT Shop Manual, Bulletin No. 3810395, for
‘camfollower lever socket rebuild procedures.
Camfollower socket, Part No 213559, is used for the 88 NT injector and valve sockets. Camfollower socket, Part No.
3039282, is used forthe 88 L10 injector and valve sockets. Camfolower socket, Part No. 3064621, is used for the 91
L10 and 91 N14 injector and valve sockets. All hee sockets have the same O.D. measurement, but have different
socket profiles.
NOTE: Do not use the socket in a model engine other than identified above. Excess wear will result the sockets
are mixed, or used with the wrong model engines, due to the different socket profiles.
NOTE: This is a product improvement not subject to campaign.
‘The following information helps to identity each socket:
Part No. 213859:
88 NT valve and injector camfollower socket. 88 NT
Sah oe baa 7
ES ee een ow -
‘Ropisiored NO. 573061 England “ere Paget ot2
Saee
‘nt nooeee90TH
Part No. s0ss292
88 L10 valve and injector camfollower socket.
NOTE: This socket has an identilication groove around
the the 0.D. for L10 engines.
Part No. s0e4e21:
91 L10 and 91 N14 valve and injector camfollower
socket,
NOTE: This socket has an identification groove around
the O.D., and two marks 180 degrees apart on top of
the socket for 91 model engines,
91 L10 and 91 N14
Identification
Page 20t2