Service Parts Dae
v me
Topics June, 1987
8714-1
“Fig Groping Fags
‘ tio
‘Subject
Cam Follower Roll Pin
Ret Engine Shop Manaar ‘Oh Wiancal Fim Gard Ger
H 04.01
The roll pin, Part No. 3029920 has been eliminated from the L10 cam follower assemblies. The purpose of the
roll (locating) pin was to make sure the
cam follower roller pin (brass pin) was positioned correctly for proper
lubrication when pressed into the cam follower casting.
‘When rebuilding a cam follower lever without a roll pin, make sure the locator hole in the roller pin (1) is aligned
correctly with the locator hole in the cam follower lever casting (2). See Fig. 1.
Note: The locator hole (1) must not be confused with the oil feed hole which is offset 180 degrees.
To make sure the roller pin is installed correctly, install a 5/64 inch drill bit shank in the cam follower lever casting
locator hole. See Fig. 2. The length of the shank that enters the locator hole, as shown in Table 1, will determine
if the roller pin is installed correctly.
Fig. 1
Fig. 2
TABLE 1: Dril bit shank depth; measured from the top of the cam follower casting to the bottom of the dril bit
shank.
Shank Depth Roller Pin Alignment
5.1 mm [0.20 in] Incorrect, brass roller pin misaligned
10.2 mm [0.40 in.] Correct
18.0 mm [0.70 in] Incorrect, brass roller pin misoriented 180 degrees
z a = indiana Form Braco
Sar ar es a a ow
Register Na 873001 cngand Page 1 of 1
copmane weer :