Professional Documents
Culture Documents
Curved members may only be created between two exis ng nodes. Any non-tapered cross-sec on is permi ed for curved
members. The internal angle subtended by the arc must be less than 180 degrees.
1. On the Geometry ribbon tab, select the Add Beam > Add Curved Beam tool in the Beam group.
Tip: This tool is contained on a drop-down list below the Add Beam tool.
3. Type the Radius of Curvature (in current units of length) and the Gamma Angle (in degrees) values.
The gamma angle,γ , is the angle between the member local Y axis and the plane of the circular arc of the member.
4. Click OK. The curved beam will is added to the model.
5. Repeat steps 2 through 4 to add more curved beams.
6. To stop adding beams:
Press <Esc>
or