Professional Documents
Culture Documents
c
c
This interface allows you to connect up to 5 playstation pads in a parallel port, having
separated Force Feedback each. You have to use an external 5V supply like a wall cube
or you can get them from inside the computer, directly from the PSU or via an USB
conector.
With this interface, the driver behaves exactly like the PSX does, turning on a bit which
sets the pad in listen mode, and every pad shares the same data cable. The other one has
a different data cable for each pad and allways set both them to listen which makes one
to timeout and therefore it stops the feedback motor.
Note: 5v and 9v negative lines and the paralellel GND are all connected to the pin 6.
These are the front view of the female conectors or the soldering side of the pad
connector.
For original NES
For NES clones
To play a boxing game like in some episode of The Simpsons
!"
#$
|y favorite to make Sub-Zero's Brutality in Ultimate |
Just make sure to have the parallel port set in ECP or EPP mode in the BIOS setup.
ADAPTADOR USB å PSX
2 Diodos 1N4148
4 resistores de 1
1 Resistor de 7 5 (7.5 )
1 Capacitor de 2u2 (2.2uF)
1 cristal oscilador de 6mhz
1 controlador USB CY7C6A-PC ou CY7C61A-WC devidamente programado.
Tirando o controlador usb o resto é simples de achar.