Professional Documents
Culture Documents
1. An agent used for class a, b, c, fires that extinguishes fire by interrupting the chemical
chain reaction in the combustion zone.
A. dry chemical B. dry powder
C. deflagration D. detonation
2. Are persons possessed with the uncontrollable desire or impulse to set things on fire,
without any motive.
A. Pyromaniacs B. Pyrophorics
C. Third degree burn D. Size of fire
4. The burning of low grade heavily oils or resinous tarry materials w/ sufficient air forms
lamp black commonly known as?
A. Biting smoke B. Detonation
C. Pyrophorics D. Soot
5. This refers to the chemical process whereby the fire consumes the most solid part of
the fuel. It is the thermal decomposition of combustible matter. It is the chemical
decomposition of a solid fuel through the action of heat.
A. Rapid combustion B. Pyrolysis
C. Burning D. Rapid burning
6. These are liquefied gases that exist in its container at temperature far below normal
atmospheric temperature, usually slightly above its boiling point with low moderate
pressure.
A. Liquefied gas B. Compressed gas
C. Cryogenic D. Natural gas
E. Inert gas
7. The term describes the transfer of heat through a gas or vacuum in a similar way to that
of light.
A. Ignition B. Convection
C. Radiation D. Conduction
13. This is defined as the chemical decomposition of a substance through the action of
heat.
A. Pyrolysis B. Combustion
C. Fire D. Heating
14. It is the manifestation of rapid chemical reaction occurring between the fuel and an
oxidizer (oxygen) in the air that produces heat and light.
A. Fire B. Combustion
C. Heating D. Pyrolysis
16. A form of energy that may be described as a condition of matter in motion caused by
the movement of molecules. It is measured in degrees of temperature to intensify its heat.
A. Fuel B. Hotness
C. Heat D. Flame
18. It is the first phase of fire, the oxygen content in the air has not been significantly
reduced.
A. Incipient phase B. Free-burning phase
C. Smoldering phase D. None of these
19. It occurs when a room or other area becomes heated to the point where flames flash
over the entire surface or area.
A. Fire point B. Temperature
C. Flash point D. Flashover
23. The temperature at which the material will give off ample of vapors that continues to
burn after being ignited.
A. Flash point B. Flashover
C. Firepoint D. All of these
24. It is any condition or act that increases or may increase in the probability that the fire
will occur or which may obstruct, delay, hinder, or interfere with the fire fighting
operations and the safeguarding the of life and property.
A. Fire trap B. Fire hazard
C. Fire condition D. Fire alarm
26. It refers to a measure of the rate of heat released by a fire. It simply means “how hot
the fire”.
A. Propagation of fire B. Intensity of fire
C. Magnitude of fire D. None of these
30. It is sudden, rapid and violent burning of heated gas in a confined area that occurs in
the form of explosion.
A. Backfire B. Backdraft
C. Backing violently D. Backfire
32. After you are sure that the electricity has been turned off to a burning electric motor,
how should the fire be fought?
A. As a class A or B fire
B. As a class C fire
C. As a class D fire
D. None of these
38. It is the graphical representation of the three elements of fire, namely: oxygen, heat,
and fuel.
A. Fire triangle
B. pyrolysis
C. Fire tetrahedron
D. self-sustained chemical reaction
40. One of the strategies used in post-extinguishment procedures that prevent excessive
damage by fire, smoke and water?
A. overhaul
B. salvage
C. exposure
D. blanketing
41. Factor that can do more damage to the building/ facility during firefighting operation?
A. fire
B. water
C. smoke
D. Heat
47. It is the accepted theory by scientists because it illustrates how the flaming
combustion is sustained through the chain reaction.
A. Fire Triangle
B. Fire Tetrahedron
C. Fire Formula
D. Fire Figure
48. According to color, it is bluish, it has also a higher temperature and does not deposit
soot because it is a product of complete combustion.
A. Premixed Flame
B. Diffusion Flame
C. Non-Luminous Flame
D. Luminous Flame
49. It refers to the chemical process whereby the fire consumes the most solid part of the
fuel.
A. Combustion B. Fire
C. Chemical chain reaction D. Pyrolysis
50. It is the visible product of incomplete combustion, usually a mixture of oxygen,
nitrogen, carbon dioxide and miscellaneous assortment of product released from the
burning material?
A. Fire
B. Smoke
C. Flame
D. soot