INTERNATIONAL’
Product Description
Audio Inlemationa's AL-SW400X is @ 200-watt, dual audio
power amplifier. This compact and Ightweight unt combines both
‘Subwoofer and stereo amplifier capabilites, which make it peroct
for almost any cabin audio experience.
‘Two (2) ALSTIOOX amps are combined into one (1) easy-to
mount and connect enclosure with a bulten 125 Hz crossover
‘This crossover provides. separate subwoofer and midrange |
‘woeter outputs for full ange performance. The Al-SWA00X unt
includes PA audio overde wth gain adjustments and nas four (2)
channels, 50 Was.
atures
Lightweight, compact size
Sold state creuty
D Two (2) 1o0-vat ampifers
D 4-channets, 50 was
Output gain contrais
DP audio input with override input (ground active)
Application Notes,
1. Auxllary power supply converts incoming +28 VDC into
+12 VOC intemal fused @ 3A. S-amp fuses atthe back of
the unit are forthe ampitier power protection.
2. Gain conttols are on the ack of the unt. Initial audio
adjustments shoulé begin at miclevel and adjusted as low as
possible to obtain acceptable cup levels vtnout distortion
3. The AL-SW400x is ulized 19 compensate for owlevel audio
signals by “amplifying” them to a higner level. The amplifier
adjustments wil be most etfecive. when the interior is
Thoroughly furnished and all pieces of furiure are in place.
‘A spectrum analyzer isthe best Lol to use in determining the
Proper ampifir settings.
1. All power and ground wires shall be 18 AWG, MINIMUM
Shielded twrsted pair withthe shila properly bonded al one
(1) end only. Power ground wires shall be bonded to
flecealy” conducive chassis mounting pont with
‘21.0 resistance of <50.0 impedance.
2, Twisled shielded “cable 'must bein accordance with
MIL-DTL.27500 or equivalent. Ensure that power and ground
‘are applied only where required
3, studs provided on the ‘font of each amplifer for grounding
ff the unit” Grounding wire must be 12 AWG minimum,
‘maximum length 3 feet atached toa sala airrame.
4, The unit must be located as close to source equipment as
possible. Long lowell runs may introduce noise into the
fue signal
5. Protect power wires with cuit breakers or fuses located
close tothe electrical power source bus
8. Ensure. that power and ground are applled only where
required
7. Allow a minimum of neh air space around the ampli due
tothe amourt of heat generated by the unit.
Dual Audio Amplifier
Al-SW400X
Tasha Spacincatons
sted DAP Raa VOCE
over | cannons power ou
{Sowots per harnel¢
anna 8 ps tai
Foner apa | “sa Wes on
apt
Impeaance 10k
rnput ever] 2007 TO 2V Taqustaoley
Input Level PA override ground active
Tama
Speaker Load 20
: Ta a oS OE
vsavoe | amined Curent rang of
” 3A)
Tang Beaker SEVOC
Ampitier ‘supply on 3 amp breaker
Wcaeal | Dimersons | — BaP aT ESTE
Iwsty | 218eme ta cn? acm
no Seow seg
Seawgs Seep
SoMa Ra RT| APSTAOOY aw
Tal eaaipon
ie aia Reto
TRAP Upsted PONT, REIT
netic Unto rnensore,Upasted
“ o6i2002 ‘Wiring Requirements and Outline
pa
PROPRIETARY NOTICE
Despite any copyright rates, this data_and information
disclosed herein contains confident, proprietary designs owned
by Aualo Internationa, Incorporated. Netter this data rar the cata
contained herein shall bo. reproduced, used, oF dsclosed to
‘anyone without the wien authorization of Auaio Intemational, In.
‘Audio Intemational Ine 7300 Industry Ori, Nor Lite Rock AR 72117 Phone 601-955-2029 / Fax 501-955-2088 /
autiint! comi =o