Professional Documents
Culture Documents
CAT 3114, 3116 and 3126 Testing and Adjusting Fuel System - Prime PDF
CAT 3114, 3116 and 3126 Testing and Adjusting Fuel System - Prime PDF
Página 1 de 2
Shutdown SIS
Previous Screen
Product: TELEHANDLER
Model: RT100 TELEHANDLER 1GJ
Configuration: RT80, RT100 TELESCOPIC MATERIAL HANDLER 1GJ00001-
01207 (MACHINE) POWERED BY 3114T ENGINE
i01324716
Illustration 1 g00701304
Fuel Priming Pump (Typical Example)
The fuel priming pump (1) is located on the top of the water separator.
2. Push down on the top of the fuel priming pump plunger and release the fuel priming pump
plunger in order to operate the fuel priming pump. Operate the fuel priming pump plunger in
order to fill the new filter element. Continue to pump until increased resistance is felt or fuel
starts to flow from the air purge valve. This resistance will indicate that the filter element is
full of fuel.
4. Start the engine. If the engine will not start, further purging of air is necessary. If the engine
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 29/03/2013
RT80, RT100 TELESCOPIC MATERIAL HANDLER 1GJ00001-01207 (MACHI... Página 2 de 2
starts but the engine continues to misfire, further purging of air is necessary. If the engine
starts but the engine continues to emit smoke, further purging of air is necessary.
5. If the engine starts but the engine runs rough, continue to run the engine at low idle. Continue
to run the engine at low idle until the engine runs smoothly.
Copyright 1993 - 2013 Caterpillar Inc. Fri Mar 29 17:02:10 EST 2013
All Rights Reserved.
Private Network For SIS Licensees.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 29/03/2013