Professional Documents
Culture Documents
Issue 03
Date 2017-06-30
and other Huawei trademarks are trademarks of Huawei Technologies Co., Ltd.
All other trademarks and trade names mentioned in this document are the property of their respective
holders.
Notice
The purchased products, services and features are stipulated by the contract made between Huawei and
the customer. All or part of the products, services and features described in this document may not be
within the purchase scope or the usage scope. Unless otherwise specified in the contract, all statements,
information, and recommendations in this document are provided "AS IS" without warranties, guarantees or
representations of any kind, either express or implied.
The information in this document is subject to change without notice. Every effort has been made in the
preparation of this document to ensure accuracy of the contents, but all statements, information, and
recommendations in this document do not constitute a warranty of any kind, express or implied.
Website: http://www.huawei.com
Email: support@huawei.com
Contents
1 Introduction.................................................................................................................................... 1
1.1 Appearance ....................................................................................................................................................... 1
1.2 Physical Ports ................................................................................................................................................... 1
1 Introduction
RRU3269 is an outdoor remote radio unit (RRU). It is a radio frequency (RF) module of a
distributed base station and is installed close to antennas.
1.1 Appearance
Figure 1-1 shows the appearance of the RRU3269.
Figure 1-2 Ports on RRU3269 700 MHz (band 12 & band 13)
The RRU3269 and the BBU are connected through a CPRI port using an optical cable to
transmit CPRI signals.
2 Technical Description
2.2 Capacity
Table 2-2 Single-mode Capacity
Mode Capacity
LTE (FDD)+ LTE For detailed specifications, see Error! Reference source not
(NB-IoT) found..
NOTE
LTE FDD receiver sensitivity is measured, as recommended in 3GPP TS 36.104, under a 5 MHz
channel bandwidth based on the FRC A1-3 in Annex A.1 (QPSK, R = 1/3, 25 RBs) standard.
LTE (NB-IoT) receiver sensitivity is measured, as recommended in 3GPP TS 36.104, under a 200 KHz
channel bandwidth and a 15 KHz subcarrier spacing based on the FRC A14-1 in Annex A.14 (π/2
BPSK, R = 1/3, 1 RB) standard.
Table 2-5 Typical output power of RRU3269 (700 MHz (band 12 & band 13), LTE (FDD))
Number of LTE Output Power per LTE (FDD) LTE (FDD) Bandwidth
(FDD) Carriers Carrier (W) (MHz)
1 (Band 12 2x40 5
or Band13)
1 (Band 12) 2x60 10,15
Table 2-6 Typical output power of RRU3269 (700 MHz (band 12 & band 13), LTE (NB-IoT))
Number of LTE (NB-IoT) Output Power per LTE (NB-IoT) Carrier (W)
Carriers
1 10
1 (SFB) 2x10
Table 2-7 Typical output power of RRU3269 (700 MHz (band 12 & band 13), LM)
1 (MIMO) 1 2x40 10 5
Table 2-8 Power consumption of DBS3900 (Ver.D) (–48 V DC) configured with RRU3269 700
MHz (band 12 & band 13), LTE (FDD)
Item Specification
Number of CPRI ports 2
CPRI rate 1.25 Gbit/s, 2.5 Gbit/s, 4.9 Gbit/s, or 9.8 Gbit/s
CPRI topology Star, chain, or load-sharing
Item Specification
Cascading capability When the rate at the CPRI port is 1.25 Gbit/s: Cascading is not
supported.
When the rate at the CPRI port is 2.5 Gbit/s:
- Four levels are supported if the cell bandwidth is less
than or equal to 5 MHz.
- Two levels are supported if the cell bandwidth is 10
MHz.
- Cascading is not supported if the cell bandwidth is
greater than or equal to 15 MHz.
When the rate at the CPRI port is 4.9 Gbit/s:
- Four levels are supported if the cell bandwidth is less
than or equal to 10 MHz.
- Two levels are supported if the cell bandwidth is greater
than or equal to 15 MHz.
When the rate at the CPRI port is 9.8 Gbit/s: Four levels are
supported.
Maximum distance The maximum distances of the RRUs from the BBU vary
from the BBU with the types of BBP in LTE (FDD) mode as follows:
When the LBBPc, LBBPd1 or UBBPd3 is configured:
20 km
When the LBBPd2 or UBBPd4 is configured: 40 km
When the LBBPd3, UBBPd5, or UBBPd6 is
configured:
− Cell quantity ≤ 3: 40 km
− Cell quantity ≥4: 20 km
LM: 20 km
Item Specification
Operating temperature –40ºC to +50ºC (with solar radiation of 1120 W/m²)
–40ºC to +55ºC (without solar radiation)
BT bias tee
DC direct current
IP Ingress Protection
RF radio frequency
RH relative humidity
RX receive
TX transmit