Polymet <> eg
‘March 2007
TIB8-008,
PeMET 730
‘Are Spray Wire
DESCRIPTION
PeMot 730 is an 316 stainless steel wire specifically designed for arc spraying. It produces dense,
‘well-bonded coatings with excellent machineabilty and wear and corrosion resistance. PeMet 730 is
\widely used for machine element repair, dimensional restoration and wear resistance applications. It
has relatively high shrink characteristics and should not be used for coatings over 0.078 inches thick.
TYPICAL DEPOSIT CHARACTERISTICS: ‘SURFACE PREPARATIO!
* Typical Hardness HRB 90-100 ‘Surface should be clean, white metal,
Bond Strength 6750 pel with no oxides (rust, di, grease, oro
* Deposit Rate 410 Ibs /hr!1008, on the surface to be coated. Note: It is
Set Detentions, 75% best not to handle surfaces after
* Wreco, 0:8 cat? m ctoaning.
Secures rei pea Recommended method of preparation
epee — isto gf Blast with 24 mesh aluminum
y oxide, rough grind, or rough machine in
“ope a peme na lathe
[APPLICATION: SPECIFICATION:
+ Part Restoration 31688
+ Rams
+ Food Industry Rolls
NOMINAL CHEMICAL COMPOSISTION (wt):
Cro Ni Mn Si Fe
170 120 20 10 Bal
RECOMMENDED SPRAY PARAMETERS:
Diameter | Air Pressure Voltage Amperage | Standoff |
Tie" (rémm)_| 60-60 psi "28-30 "700-200 | *4=-6in (10- teem) |
rite are Ss and may vary dapendig an SGUpmant used. Cowal out equiped ManAGAUTe er pl STAY paIaMES
STANDARD SIZES & PACKAGING:
Diametor Packaging Part Number
46:8) 258 CLS 730062L0NS01|
peed wa yo anc be conn egrets cl reptie nat dpecng on atari cnn Pes ate
‘Blairs cs ied tg hots tel arash ats ale Poron aan ere Sake
10073 Commerce Park Drive, Cincinnati, OH 45246 / Phone: 613-874-0686 / Fax: 519-8742880
sales@polymet.us