Professional Documents
Culture Documents
hi i'm matt shelly here today to of the circular bubble move the leg up
demonstrate how to set up over a point and down till you're satisfied with
with the total station after taking the position of the circular bubble and lock
total station out of its case mount the with the clamp to continue leveling
total station with the tripod screw and we're going to raise and lower a second
center the machine on the tripod head leg keep in mind that the circular
before securing with the screw bubble is only rough level and that fine
typically the foot screws are different leveling must be done with the plate
positions in their travel before you level in order to level the plate level
start setup over a point rotate the foot you must use the foot screws start by
screws to be at mid point of their placing the sides of the machine over
travel this total station is quit with a two foot screws and level the plate
laser plummet to start you must turn the level over those two foot screws now
power on after waiting several seconds turn the machine 90 degrees so the sides
from the machine to fire up press star of the machine over this last foot screw
f3 to turn the laser on the laser and level the plate level with this last
plummet projects the center of the total foot screw only now the total station is
station right down to your point in the level you must check that the laser
field the laser would be much more plummet is still centered over the point
visible to Center the laser plummet over if not you must loosen off the bolt on
the point pick up to the legs of the the tripod and move the Machine
tripod and jockey the legs around to get frontwards or backwards or side to side
the laser as close to center as you can without twisting to get the laser
get it now step in all three foot pegs plummet over the point then secure the
firmly into the ground bolt once again now that the laser
the action of stepping in the footpegs plummet is REE centered re level the
will throw you off center use the foot plate level you never satisfied until
screws to recenter the laser plummet the plate level is level no matter which
perhaps the most complicated part of way you rotate the machine and the laser
that by raising and lowering the legs to over the point these are the steps to
level the circular bubble grip the left setup over point
side of the leg with your left hand and it's very tedious and exacting process
the clamp with your right to move the becomes easier practice
you