Professional Documents
Culture Documents
shtml
This cable can be used to connect two computers together without a hub, or to connect two hubs
together (without using an uplink port). If you are connecting two hubs together and one of them
has an uplink port, use a straight cable. Most hubs nowadays are autosensing.
In order to make Crossover Ethernet cable wire one RJ-45 connector using the T-568A standard and the
other RJ-45 connector using the T-568B standard.
8 pin RJ45 (8P8C) Ethernet crossover cable pin assignment: 8 pin RJ45 (8P8C)
male connector Name Pin Pin Name male connector
at the network interface card 1 at the network interface card 2
TX_D1+ 1 3 RX_D2+
TX_D1- 2 6 RX_D2-
RX_D2+ 3 1 TX_D1+
See also:
RX_D2- 6 2 TX_D1-
BI_D3+ 4 7 BI_D4+ Ethernet 10 / 100 / 1000 Mbit
wiring diagram and cable
BI_D3- 5 8 BI_D4- pinout
BI_D4+ 7 4 BI_D3+
BI_D4- 8 5 BI_D3-
Note 1: It´s important that each pair is kept as a pair. TX+ & TX- must be in the pair, and RX+ & RX- must
together in another pair etc. (Just as the table above shows).
Pinouts.ru > Network cables schematic > Pinout of Ethernet 100Base-T4 crossover cable and layout of 8 pin RJ45 (8P8C) male connector and 8 pin RJ45 (8P8C) male connector