Maintenance
General maintenance
Periodic chacks on Blokset must be cared out in accordance with the apelicable
regulations.
Periodic maintonance must be caried out once a year or more, dopending on the
stipulations in the serving conaitions and the maintenance contract.
FO
HAZARD OF ELECTRIC SHOGK, BURNS OR EXPLOSION
Tur of temo supine ouiprantbefoewerlngen KA
hazard of electric shock, bums or explosion exists whenever working in
fF around the equipment.
Failure to observe these instructions will result in severe bodily
injury or death.
Maintenance on fixed parts
of the switchboard (see Fig. 1)
Common maintenance operations forthe entire range.
1 Check inside and outside the Switchboard for moisture or foreign materia,
Remove ary foreign materal and clean the switchboard.
‘Use a veduum leaner to clean If necessary, cles the ventilation system and
‘change the filers.
t Clean old grease of ll mechanical parts and regrease lightly (et. 87635).
f= Examine the outer nish ofthe switchboard, necessary, touch up any paint
Soralches and replace any damaged or usted parts,
' Check te nauation monitoring devices.
f= Run tests on the indication systems.
# Visually sheck the busbars:
1 Assenbly screws for busbars do not require to be tightened as long asthe
‘amish andthe guarantees comeet tightening torque, i intact;
1 Visual inspect to detect any hot points (change in colour).
Ha hot points detected, the assembly must be dismounted. Clean and sand the
‘contact sufaces (sand paper grade 400), When remounting:
Use identical (sass 8) new hardware (Bas, nuts and washers),
Tighten 2s indicated in the table below.
= Apply vamish.
Visually sheck the condition and tightness ofthe busbar supports,
Check te tightness ofthe customer cables,
f= Run a cteck on the switchgear devices.
= Consult he corresponding manuals.
‘This table dicate the correct tightening torque for ass 8.8 hardware with nuts
‘ang contac washers.
Diameter of bok Tightening torque (Nm)
rut with contact washer
3 15
Ma 35
NS 7
NG 13
Ne. 28
uo 50)
M2 L 75
ta 720
M6 705
ie 260
M20 370
NOTICE
1» Do not clean using compressed air to avoid blowing contaminants
to other surfaces.
«= For cleaning purposes, use dry cloths or cloths dipped in