Professional Documents
Culture Documents
Use Manual of UV Disinfection Lamp
Use Manual of UV Disinfection Lamp
Control Panel
Base
♀'
Remote Control 头|@@@
Product Parameters
叫二
卜一计
们川川川u
Product Size:
Baseφ180 * 18mm
n川川川u
卜臼180mm 一十卜臼180mm寸
Instructions
1.After the power is turned on, the disinfection table lamp enters the standby
mode. The red indicator light above the ON / OFF key will flash, and the buzzer
will sound a ‘D’, indicating pairing with the remote control. After the pairing is
successful, the red indicator light is always on to enter the standby mode.
3. Timing mode: When the 15MIN / 30MIN / 60MIN button on the control
panel or remote control is pressed briefly, the yellow indicator above the
timer key on the control panel flashes quickly, the red indicator above
the ON / OFF key is always on, and the buzzer " After the D "D" sounds
for 10 seconds, the disinfection lamp starts to work; after the work starts,
it will automatically end after 15 minutes / 30 minutes / 60 minutes
according to the set time. At the end, the buzzer will emit a "D" sound,
red The light is always on.
。
。
。
。
When the timer mode is running, if you need to stop the work, press any
@
⑩
button on the control panel to stop the UV lamp work.
⑧
@
4 Human induction:
No matter what mode, when a person or pet approaches, the built-in sensor
of the disinfection table lamp will sense it, the buzzer will emit two 'D' sounds,
and then the table lamp will stop automatically To prevent people or animals
from being burned by ultraviolet rays, the lamp will restart 45 seconds after
the person or animal leaves; in the timekeeping mode, due to the induction
川ω
interruption, the light will continue to work after the person or animal leaves
\\l/
\-J
/fi飞
*
分
5. The remote control has the same control function as the control panel, and
the maximum wireless distance in the wall is 30 meters.
Precautions
·It is forbidden to look directly at the ·During use, the surface of the disinfection
ultraviolet lamp, and it should be used first lamp should be kept clean. When dust or oil
without people, pets or plants. Prolonged stains are found on the surface of the lamp
exposure to ultraviolet rays may cause skin tube, it should be turned off and wiped at
burns, irritation of the conjunctiva, and any time, otherwise the germicidal effect of
damage to plant cell walls. the lamp will be affected.
关C 得L
·When disinfecting with ultraviolet light, ·When the surface of an object is disinfected
the room should be kept clean and dry, with ultraviolet rays, the surface of the object
and dust and water mist should be to be irradiated should be directly irradiated
reduced. When the indoor five poisons are within 1 meter of ultraviolet rays, and the
lower than 20 ° C and higher than 40 ° effect is better.
C, the irradiation time should be
appropriately extended for 15-30 minutes.
·When disinfecting pet houses and ·If there are calligraphy and painting
children's rooms, keep pets and young collections or plants in the sterilized
children away from UV lamps and ensure space, cover them with cloth or remove
that they do not touch the disinfection them from the room during use.
table lamps and cause injuries.
Instructions for replacing the lamp
Step 1: Align the lamp port with the base bayonet and insert it vertically, and
check whether the connection is firm.
川I .r-
Step 2: Confirm that the installation is complete, and you can use it after turning
on the power.
Note:
Before you need to replace the lamp, please contact the
manufacturer to obtain a lamp that matches this product.
The factory is not responsible for the loss caused by the
privately purchased UV lamp replacement.
Accessories list
1. Principle of UV sterilization?
Answer: Ultraviolet C-band irradiates microorganisms and destroys the DNA (deoxyribonucleic acid)
and RNA (ribonucleic acid) of various bacteria, viruses, and microorganisms, so that bacteria, viruses,
and microorganisms lose their viability and reproduction ability to achieve the effect of disinfection.
6. How long can the lamp be used? How to carry out after sales?
Answer: The lamp life of this sterilized table lamp is 8000 hours, and the products enjoy a one-year
warranty service (except for man-made damage).
7. Is there any foreign body in the lamp that will affect it occasionally?
Answer: The small white particles sometimes seen in the lamp tube of ultraviolet disinfection lamp are
mercury particles. Because the principle of ultraviolet disinfection lamp is to stimulate the eastern
vapor in the lamp tube to emit light. There may be a small amount of particle deposition in the lamp,
which is normal and does not affect the use.
Fault Resolution
The host can operate, Please check whether the remote control has
but the remote control power or the battery is not in good contact.
cannot operate
Why is there no ambiguity According to the size of the room, make sure that
the UV disinfection lamp completes the normal
after being sterilized after
work for at least one time period, and the doors
being sterilized?
and windows need to be closed during
disinfection.
Precautions:
If exposed to ultraviolet rays for a long time, people's skin and eyes will be burned; long-
term inhalation of ozone will hurt people's respiratory tract; therefore, doors and windows
must be closed during disinfection, and people, plants and animals must be kept away
from