LIMITS HOME SW, AND EMERGEN
ON THE TB6560 BOARD
MULTI AXIS DRIVER BOARD
5 pin white
connector
on the board
dbes
|
dS
Lt
pin 10 input, Shown here Shown here wired to pinl0
pin 10 input
pint inaut Wired to pinll (an it nous ‘e
\ye 12 input Bin 12 ingut **tin|
pin_13 in jein te in
GN | You can whe a series of
i tints wth Norrally Closea
switches, ond set your software
fon active high trip,
be detected
These 4
Emergency
stop switch
can be wired either
normally closed or
normally open
set software
either way
\|
5S pin white
5 pin white
connector i
connector,
protect
Y STOP WIRING
Pin 10 limit
Pin 11 limit
Pin 12 limit
Pin 13 |
Ground Pin
Pins 10, il, 12, and 13 at the
computer print port are normally
45 volts, By shorting the pins
of the small white 5 pin connector
to ground, sends the print part
corresponding pins low (volts)
the software if set active low
senses a limit signal trip, or
if you keep these pins
shorted to ground, through
a series of NC limits, then an
open trip on any one will trigger
a limit trip if the software is
set to active high.
input points
are opto-isclated to
your computer