Professional Documents
Culture Documents
ALCATEL-OMNIPCX-INSTALL-MANUAL (337-678) (PDF - Io) (2) (1-56) (15-20) PDF
ALCATEL-OMNIPCX-INSTALL-MANUAL (337-678) (PDF - Io) (2) (1-56) (15-20) PDF
IP TELEPHONY
This service does not require any specific external equipment (IP and/or Proxy/Firewall Router), unless
it is provided for Remote/Home Workers.
Pimphony
@IP
MultiMedia
Remote worker
Alcatel OmniPCX @IP1
@ IPn Pimphony
(DHCP Server) MultiMedia
Permanent connection VPN
@IP
R Public @IP WAN IP network
@IP
IP ENABLER
@IP
R
LAN
Pimphony
MultiMedia Home worker
Company
@IP : IP Address
R : IP/Proxy/Firewall router
VPN Server
The IP router (R) connected to the Intranet can be a simple IP router. The reservation of bandwidth is
"guaranteed" if this router supports IP ToS (DiffServ).
The number of remote IP Enablers or PIMphony IP subscribers depends on the line bandwidth (not
more than 2 simultaneous communications for 64 Kbps, not more than 5 for 128 Kbps).
IP ENABLER
Home Network
IP ENABLER
Alcatel OmniPCX
Internet
R/F R/F
Permanent
connection VPN Permanent
connection IP ENABLER
LAN
R/F: IP/Firewall router with permanent
connection (leased line, ADSL,
Company modem cable) +VPN Server
The connection between the Home Worker and the Internet must be 'always-on' (ADSL, cable, etc.). It
is indispensable to have an IP/Proxy/Firewall router or VPN server on the Home Worker side.
The IP router (R/F) at the front end of the VPN must offer Proxy/Firewall and VPN server functionality
(IPSec with 3DES encryption for interoperability with the system's built-in router).
The number of remote IP Enablers or PIMphony IP subscribers depends on the line bandwidth (not
more than 2 simultaneous communications for 64 Kbps, not more than 5 for 128 Kbps).
IP ENABLER
Remote Worker
IP ENABLER
Pimphony IP
Alcatel OmniPCX
Internet
R/F
Permanent dial-in
connection VPN Connection
ISDN / PSTN
Pimphony IP
The connection between the remote PC (PIMphony IP Edition) and the Internet is of the "dial-on-de-
mand" type (V90 analog, ISDN BRA or ADSL modem). The remote PC first establishes a connection
with the nearest access provider, then a PPTP connection with the company's VPN server.
The remote NetMeeting PC establishes a PPTP connection with the company's VPN server.
TOPOLOGIES
This section describes typical IP network architectures for implementing the Alcatel OmniPCX Office
Voice over IP services.
Alcatel OmniPCX
Internet
CoCPU@ Board (Internet Access)
Server
LAN Switch
10/100 Mbps
The bandwidth of an Ethernet LAN can be 10 or 100 Mbps. If the network operates at 100 Mbps, ad-
ding terminals operating at 10 Mbps risks downgrading the bandwidth used by VoIP and hence audio
quality: you might need to isolate these devices on external LAN switches hooked up to the system.
CoCPU boards are connected to the local client network using a LAN switch; this solution helps reduce
Ethernet traffic on the CoCPU board.
Multi-site configurations
Alcatel OmniPCX
Extended Intranet
R R
Permanent
connection
ISDN / PSTN
LAN
G : H.323- compatible gateway
R : IP router with permanent
Company connection
The IP router (R) connected to the Intranet can be a simple IP router. The reservation of bandwidth is
"guaranteed" if this router supports Ipv4 ToS (DiffServ).
Alcatel OmniPCX
Internet
R/F
Permanent VPN Permanent
connection connection
G
ISDN / PSTN
Pimphony IP
IP ENABLER
@IP
IP ENABLER
Alcatel OmniPCX
R R
Permanent
connection
Pimphony IP IP ENABLER
ISDN / PSTN
LAN
R/F: IP/Firewall router with permanent
Company connection (leased line, ADSL,
modem cable) +VPN Server
Nota : See also the Home Worker and Remote Worker topologies described earlier.
IP ENABLER
IP ENABLER
Pimphony IP
Alcatel OmniPCX
LAN
RAS : Remote Access Server
Company
The RAS is equipped with a pool of modems or a T0 / T2. The RAS client PC is authenticated by a PAP/
CHAP authentication procedure, then is called back by the RAS (call back).