Professional Documents
Culture Documents
EXPERIMENT - 5
Modeling of Component in 3D – V block
Drawing:
V-BLOCK
Procedure:
Give the dimensions to the rough sketch as shown below, using ‘constraint’ Icon of ‘constraint tool bar’.
25 10
25
10
50
Click on ‘Exit work bench’ icon in the ‘work bench Tool bar’’ to exit from sketcher work bench to
‘part design work bench’.
Select ‘pad’ icon from’ sketched base features tool bar ‘and give the length of extrusion /pad i.e
50mm.
Save the file.
EXPERIMENT - 6
Drawing
Procedure:
Give the dimensions to the rough sketch as shown below,using ‘constraint’icon of ‘constraint tool
bar’.
AUTO CAD MANUAL II-I
20
60
20
60
Click on exit work bench icon the work bench tool bar to exit from ’sketcher work bench ‘to part
design the work bench’
Select a ‘pad icon from sketched base features tool bar’ and give the length of extrusion /pad
100mm.
Select the plane on which semi circular hole to be created and select sketcher.
Draw the closed semi circle as shown in figure using profile tool bar and give the dimensions as
shown in the following figure by using constraint icon of constraint tool bar.
Click on exit work bench icon. Now select pocket icon from sketched based feature tool bar to
remove the material and give the length and depth as 20mm.
Select the required plane on which slot to be created and click on sketcher icon .
Draw the slot and give the dimensions as shown in figure.
RRrrr
40 30
AUTO CAD MANUAL II-I
Click on exit work bench icon. Now select pocket icon from sketched based
feature tool bar to remove the material and give the length and depth as 20mm
To Required model is created now save the file.
EXPERIMENT - 7
AIM: To draw the othographic projections of the isometric figure given below.