Professional Documents
Culture Documents
SATELEC Scaler System (153765-001, 005) Procenter Delivery Unit Installation Instructions
SATELEC Scaler System (153765-001, 005) Procenter Delivery Unit Installation Instructions
Scaler Tubing:
(153765-001, 005) Procenter Delivery Unit Components ...... 1 1/8 " Clear ........ AR
Installation Instructions Pressure Swt. .....
Check Valve ........
1
1
1/4" Clear ......... AR
Fittings:
Washer ............... 1 1/16" barbed T ... 1
Intended Use: Wire Connector ... 1 Uni-Clamp 1/8" ... 5
Velcro, Loop ........ 1 1/16" to 1/8"
To provide a means for a dental hygentist to remove
Velcro, Hook ...... 1 barbed ............... 2
plaque and build-up on patient’s teeth.
Bracket ............... 1 1/16" barbed
Cover ................. 1 plug .................... 2
Requirements / Restrictions: Screws ............... 4
None Special Tools:
none
Kink
Step 5: Disconnect 1/8" Valve
green tubing.
KA975501i
Indicator
Step 2: Install scaler holder bracket
10
on bottom side of delivery
9 1
2 unit housing, secure with
8
7
6 5 4
3 two screws.
1/8"
Pressure Clear
Check
Switch
Valve Step 1: Plug off end of Exhaust Air
1/8" tubing using a 1/4" - 1/8"
Clear Plug Reducer, 2" length of 1/8"
Clear tubing, uni-clamps,
To sleeve clamps, and a plug
Pressure
Gauge 1/4" 1/8"
Clear Clear
A
Step 2: Plug end of Coolant Air (1/8" Step 3: Connect 1/8" Clear tubing from
Green) tubing using a 1/8" plug
and uni-clamp. Scaler Handpiece to Kink Valve
Kink (A). Use uni-clamp to secure.
Valve
Scaler
Handpiece
1/8" Clear
Terminal Tubing to
Board Kink Valve
Note
Loop each wire thru
EMC Filter once.
EMC Black
24V Filter
Wire
From Grey Connector
0V
Potentiometer
Connector on
Controller
White
White Pressure
Switch
Black
Grey
Midmark Corporation
Potentiometer
60 Vista Drive From Scaler
Versailles, OH 45380-0286
Controller
Handpiece
Phone: 937-526-3662
Fax: 937-526-5542 KA975802i
midmark.com