Professional Documents
Culture Documents
FEATURES APPLICATIONS
• Imparts water repellency to a
wide variety of substrates • As a surface treatment in applications that utilize its ability to impart a
water repellent surface and reduce water absorption
BENEFITS • For use on bricks, sandstone, limestone, and ceramics
• Reduces water absorption into
substrates, thus reducing spalling TYPICAL PROPERTIES
due to freeze-thaw and Specification Writers: These values are not intended for use in preparing
efflorescence specifications. Please contact your local XIAMETER sales representative prior to
• Colorless and non-yellowing writing specifications on this product.
protection preserves the natural Test Unit Value
appearance of substrate Solids Content, after 90 min at 150 Co
% 40-45
• Penetrating and breathable (302oF)
• Low VOC Silicone Solids content % 24
• Nonflammable Specific Gravity at 25oC (77oF) 1.29
o
Flash Point, open cup C (oF) >93.8 (200)
COMPOSITION pH 13
• Water-dilutable potassium methyl Density lb/gal (g/L 10.8 (1290)
siliconate solution Solvent (thinner) Water
• Clear to slightly yellow Volatile Organic Compound lb/gal <0.417 (<50)
Content (g/L)
% Water
% Active Exclusion vs % Weight
Substrate Total Solids Control2 Adsorption3
Sandstone4 1.0 93 0.6
3.0 87 1.1
5.0 82 1.5
Control 8.6
Limestone5 3.0 74 1.4
5.0 75 1.3
Control 6.0
Belcrest 760 1.0 94 0.4
(Red Brick) 3.0 86 0.7
5.0 86 0.7
Control 6.0
Beldon 691/693 1.0 95 0.2
(Gray Brick) 3.0 95 0.2
5.0 88 0.5
Control 4.5
Camfered Cocoa 1.0 96 0.1
Paver 3.0 89 0.2
(Dark Red) 5.0 87 0.3
Control 1.9
Illinois Common Brick 3.0 96 0.7
(Light Red) 5.0 96 0.7
Control 17.2
1
Federal Specification SS-W-110C Testing – sample supported in ¼ inch (6 mm) of water for 72
hours.
2
Calculation is based on weight gain of control.
3
Calculation is based on weight of block before soaking.
4
1” x 1” x 4” (25 x 25 x 102-mm) blocks of Briar Hill sandstone
5
1” x 1” x 4” (25 x 25 x 102-mm) blocks of Indian limestone
Application Precautions metals. If contact does occur, wash INFORMATION. THE MATERIAL
• Always test the concentration on a immediately with water. SAFETY DATA SHEET IS
small sample of the material to If a white precipitate of potassium AVAILABLE ON THE XIAMETER
determine the suitability of your carbonate should form because of WEBSITE AT
specific use. over-application of water repellent and WWW.XIAMETER.COM.
• Surfaces to receive the water- washing with water does not remove it,
soluble silicone should be lightly it may be necessary to scrub the USABLE LIFE AND
dampened immediately prior to surface. STORAGE
application. When stored at or below 25oC in the
• This water-soluble silicone does not PRODUCT SAFETY original unopened containers, this
wet surfaces that have been INFORMATION product has a usable life of 36 months
previously treated with silicone or PRODUCT SAFETY from the date of production.
another water repellent treatment. INFORMATION REQUIRED FOR
• When spraying XIAMETER OFS- SAFE USE IS NOT INCLUDED IN
0777 Siliconate, great care should
LIMITATIONS
THIS DOCUMENT. BEFORE This product is neither tested nor
be taken to protect nearby HANDLING, READ PRODUCT AND represented as suitable for medical or
vegetation or articles from MATERIAL SAFETY DATA Pharmaceutical uses.
overspray. The material is very SHEETS AND CONTAINER
caustic. It will damage or kill LABELS FOR SAFE USE,
vegetation and will stain or etch PHYSICAL, ENVIRONMENTAL,
glass, plastic, aluminum and most AND HEALTH HAZARD
LIMITED WARRANTY
INFORMATION – PLEASE
READ CAREFULLY
The information contained herein is
offered in good faith and is believed to
be accurate. However, because
conditions and methods of use of our
products are beyond our control, this
information should not be used in
substitution for customer’s tests to
ensure that Dow Corning® and
XIAMETER® products are safe,
effective, and fully satisfactory for the
intended end use. Suggestions of use
shall not be taken as inducements to
infringe any patent.
XIAMETER® OFS-0777 Siliconate September 15, 2009 XIAMETER® is a registered trademark of Dow Corning Corporation.
Ref. No. 95-435B-01 Dow Corning® is a registered trademark of Dow Corning Corporation.
©2009 Dow Corning Corporation. All rights reserved.