Professional Documents
Culture Documents
Gba Back Light Instructions v41 PDF
Gba Back Light Instructions v41 PDF
® MODIFICATION KIT
1
L I G H T
® MODIFICATION KIT
1) 2) 3) 4) 5) 6) 1) 2)
3)
1) Plastic Pry Tool or Small Flat Screwdriver 1) NEW LCD screen (AGS-101)
2) Small Tri-Wing & Philips Screwdrivers
2) Adapter Ribbon Cable
3) 15W-30W Soldering Iron & Solder (either 32 or 40-pin motherboard compatible)
2
L I G H T
® MODIFICATION KIT
4) Remove LCD with a 5) Gently push clear Tools & Parts Required:
plastic pry tool or small lens out with a soft
flat head screwdriver, towel/cloth and set
then pull away the aside in a clean area.
sticky black border.
©2013
3
L I G H T
® MODIFICATION KIT
4) Using a hobby knife 5) Place new LCD in Tools & Parts Required:
or rotary tool, the shell to test fit.
completely remove any Trim more plastic if
of the marked needed until LCD sits
walls/tabs. flush.
©2013
4
L I G H T
® MODIFICATION KIT
3) Attach adapter
1) The LCD ribbon 2) Fold the ribbon cable cable to PCB with the
cable needs to be as into a “Z” as shown. contacts facing up,
folded in order for the then slide the locking
new parts to fit. clip back down using
the tabs on either side.
4) Locate this area on 5) The left leg of “DA1” Tools & Parts Required:
the back of the PCB. is where you will solder
the wire which leads to
the adapter.
©2013
5
L I G H T
® MODIFICATION KIT
1) You may want to put 2a) This is the 32-pin 2b) This is the 40-pin
a small piece of tape adapter. Solder the adapter. Solder the
down to help prevent other end of the wire other end of the wire
short circuits/solder to “P1”, which is to “P1”, which is
bridges. highlighted here. highlighted here.
6
L I G H T
® MODIFICATION KIT