Instructions
Model A30 Amplifier
30-watt Circlotron
High-Fidelity Li
Amplifier
GENERAL DESCRIPTION-The Eleciro-Voice Model A30 amplifer is a high
quality So-wat line amplifier with provision for supplying the power necesary to
yoviated remove control and presmpliber equipment. Convenient
Plugsin conoections are provided for this purpose. The polished chrome and
black baked enamel Bnish presents an aticactive appearance and provides m
‘rues protection against corrosion
PEATURES—No output tube DC in transformer. ‘The Model A30 employs she
new Wiggins CIRCLOTRON circuit, DC outpue curtent i¢ removed from
‘the ourput transformer through the use of a bridge ciccwit. ALI switching ta
siesus are eliminated through unity coupling of output tubes; class AB, operation
is efecied with the resultant improvements in power output, efficiency and tube
life. The primary impedance of the output transformer is one quarter of shat
found in conventional amplifer output circuits, affording a vast increase io poner
‘ourpet at extremes of the frequency spectrum
es
A damping factor control permits perfect coupling between the amplifier and
loudspeaker system eliminating the usual loss of bass from overdampiog or
hangover due to uaderdampiag. For the Grst time, shrough the use of this
wou, optimum operation of any speaker system is assured
Fig. 1— Model A30 Amplifier SPECIFICATIONS
Power Output 30 wer rated, 60 wom on peoks
See Fig. 2. "Moximom Undintorted
va Frequency”
Frequency Response +£0.25 db 2010 70,000 eps at roted output
Sen Fig. 3 “Frequency Response”
Harmonic Distortion: Les thon 0.55 ot rated output
Intermodlation Distortion Le thon 19% et rated output
See Fig. 4 “Power vs. Intrmodultion Owronton
Hum and Noise: 90 db below rated output
dy aurT OEY 1ePIW ADIOA-OLIIIa 43)
‘Sproker Output ‘ohms, 8 ohms, 16 ohms unbalanced:
600-ohm bolonced
feedback Loop feedback: 16.db negotce
Dive pote, 2db penne
Ouipercrcut, 17 db negara
Toto! Vb negetve ,
Fig. 2— Maximum Undistorted Power }
vs. Frequency Damping Focer Adjntoble behewen 0.1 and 15. Sew tebe for
@ Gita! domping foun of ll specks
Input mpedonce 230,000 ohm
Sensi 1asy ensFig. 3—Frequency Response
Fig. 4— Power vs. intermodulation
Distortion
Fig. 5 — Affixing Mounting Brackets
con
Power On-Off
than Adjmant
Tabew Total of 6.0 follows
1 0X7
1 12mH7
2 866o
2 sacr
Power Consumption: 117V @ eyel AC ot 1.3 omps max. Bultin power
swpply for Medel PRC! or PRC? preamplifier ond
remote contrl oni
Accenory Power Available: 280¥ DC ot 10 MA
or Preamp, Remote Control Unin) 18V DC at 150 MA,
63V AC ot 1.05.4
Size: 19% in. wide 834 In. dap x7 in. high
Weight: 22 fo na, 25 Ib shipping
INSTRUCTIONS FOR SET-UP AND OPERATION
Immediately upon unpacking she amplibr carefully inapect it for physical dam-
‘ae. If damege is evidenced, notify the dealer from whom the unit was purchased,
(oF the transportation company ifthe unit was shipped to you. Responsibility for
shipping damage lies with the carrier and claim should be made for recovery
MOUNTING—The A30 muy be mounted either in a9 upright postion or verti-
‘ally, with the coatrols toward the 1p bottom.
‘The ampliser is supplied with rubber feet to prevent
which
ring of the surface on
placed, For mounting in 2 vertical position or for Sxed upright
(See Fig. 5 “Atizing Mounting Brackets") remove these feet by
‘extactiog the sctews located in the center of each rubber foot. Install one
smovating bracket in the desired location on supporting wall or surface with the
‘hooks pointing up. Is
‘bottom plate nearest the top
racket tothe support
able ventilation is requiced, and the unit should not he operated in small, com
pletely enclosed spaces. Brackets may also he used for permanent horizontal
‘mounting Under unasual conditions of very eewricted ventilation, the tube and
Component cover may be removed to assist cooling, Spec
able for rack mounting: order in puis as Part No. 72094,
PREPARATION FOR USE — Make certain that all tubes are firmly sented in the
proper sockets a1 marked. Connect the loudspeaker or other load 0 the ampl-
fer using the two black bananetype plugs supplied. Matching to any loud
between approximately 3 and 20 ohms may be obiained by plugging into the
six-proog socket on the tear apron of the amplifer. Use the pint marked
“COMMON” and either "4", "H", of "1G", whichever is nearest the loed is
pedance. De eet exteraelty ground any portion of the eetpet clralt. A 6OO-ohe>
balanced output is alto available at this socket. When using # 600-ohes load, do
not connect to the "COMMON" pig, The Electo-Voice PRC1 nc PRCZ remote
‘control ensemble is recommended for use with the A30 amplifier. Two sockets
fon the rear apron of the ampliber are provided « supply power uo this aquip-
‘ment. Connect the input signal to the jark marked “SIGNAL” on the cear aproo
of the ampliéer, using phig supplied, if desire.
CONTROLS—Three knobs and one screwdriver adjusiment are located wear the
right fromt corer on top of the ampliber. The gxin conirol adjusts the seantivity
‘of the amplifier to match the sociated equipement
Seater E
4damping contol isan Becro-Woice development designed ta permit pecse
Richey ot oe 230 ay enining spss aynem: Comma abe fr fore
trwings for Elecvo-Voice speaker system Adj for sxat pleasing sound if 0
ins isavalable for other loads. For maximum damping (low internal imped.
Since), tan knob compltelf clockwise. When aslng 608-shm wetpet connec:
Vion: domping esttrel met I tet te full clochwine penton, ead deer eet
pores 00 tls imposanen,
“The power “ON-OFF-REMOTE” switch functions as the AJ “ON-OFF”
such whea power control is desiced a the amplifer location. The PRC units
reals contcolled by this sjih
For remote control of the equipment, when concealment of the amplifier is
desired, urn this switch 10 the "OFEREMOTE” postion, This will allow the
PRC preamplifier power swaich wo function as the aster power control
‘A hum balancing control is provided for use when the amplifier is used with
Hleciro-Voice PRCT or PRC2 temote coetzol equipment, To adiuse this hua
control, remove the acorn nut by caring counterclockwise, This will expose
the screwdriver slot adjustment. Adjust for minimum hum wader operaing
conditions. Replace acorn aut. No hum adjustment is required unless the PRE
sits are connected
LINE-POWER SERVICE FOR OTHER EQUIPMENT-—Two line-power outputs are
provided on the rear apron of the amplifer. The one marked "HOT" supplies
the power whenever the amplifier is plugged in regardiess of the power switch
position. Sach an oullet fe commonly used for devices having thelr ow ono
switch. Use of this utlee will permic a record changer to complete a change
cycle before complete shatofl. The outlet marked “SWITCHED” is live only
when the amplifer is toned on and may be used to conical the tuner. TV set. et
The power onl switch should be set at “OFF-REMOTE™ posivon when the
amplifier is controlled by PRC units,
SERVICE The Zampere fuse located on the rear apcon of the ampliber is of
the “sloblo” 3AG 1ype and in the event of » component failure, should be
feplaced with an ideatical ampere «ype. The fase will not blow wormal
‘operation. In the event of repeated Failure’ (4) make cervain ample is mounted
snd connected in accordance with these iasiuctions, (B) check tubes for possible
shorts and replace if necessary. oF (e) tele to the dealer from whom purchased
for iasirustions. Access 19 tubes may be gained by removing the two wrens
located on eather side of the wp of the protective cage, This cage may then Be
removed, De set attempt te operate the amplifier witheat all tober la place
(end plate caps connected.
CAUTION NOTES:
1. Do no operate amplifier in an overloaded condition for a period of «i
this will substantially shorten the life of the output tubes,
2. Do moc attempt to operate the amplifier on 4 power snurce other than
OPTIONAL ACCESSORIES del PRCI Preamplifier and Remote Control
Units, Model PRC2 Peeampliber and Remote Conttol Units. Rick Mowat.
Suraps Pact No, 72004.
CRITICAL DAMPING FACTOR CONTROL SETTINGS
——
PARTS LIST
“Cl Copoctor, 1 MFO, 200 V, onic Tublor
C2 Copoctor, 50 MMF, $00 V, Ceromic = 20%
(C2 Capoctor, 20 MFD, 450 V, Encrolyne
C4 Copoctor, 022 MFO, 40 V,PoncTabstor
(C3) Copocior, 047 MFO, 40 ¥, Poni Tubslor
Co Capacitor, 047 MED, 40 V, Powe Testor
7 Copocier, 1 MFO, 600 V, Plow Tubular
CF Copacior 30 MED, 100 ¥, tlecsyie
10 Copecior 40-40 MFD, 500 V, Electrolytic
CLI Copoctor, 4040 MD, 500 V, Eleioyie
{C12 Capoctr, $00-500 MED. 28 V, Elect
C13. Capoctor, 047 mF, 400 ¥, the Iubulor
{C14 Copocier 047 MFD, 400 V, Poe Tubular
C13. Copoctor, 01 MED, $00 V, Cermic GM
C16 Cepocior 01 MFD, 500 ¥, Ceramic GY
+81 Povaemaer, 2906, A Toper cuca
BD Rast, 270K, W, Carbon, 10% 4809
39 Reiner, 27K, 4 W, Coro, 10% 455
saat Potetometer | gag Ori 2A Linwar Aaa
Setar, 27 OHM 1W, Carbon, =5% 4880
6 Resor, 3K, 6W, Carbon, 10% ss
RT Ravine, 470 OHM. HW, Carbon, =10% 4854
28 Restor, 27, HW, Carbon, = 4551
9 Ranier, 1.2 MEG, ‘a, Corbon, 4856
IO. Rater, 58, 6W, Corban 4852
NY Resin, 36K, SW, Carbon, = 10% 4852
R12. Revie, 470K, 4W, Carbon, =10% 490
213 Raster, 4706, HW, Carbon, =10% 4630
R14 Raitor, 126, 70, Caran, = 1086 40
IS Renter, 12K, 20, Carbon, =10% an
18 Renter, 126, WW, Carbon, =10%6 480
7 Reitor, 47, HW. Carbon. 10% 4658
RIB Resin, A7OK, HM, Corbon, = 10% 4850
A19 Reiter, 470K, 9M, Carbon, = 10% eso
20 Resto, 100 OHM, 4, WW. asa
2). eshte, 100 OHM, 4, W.W. ee
N22 Resite, 39K, DW, Carbor, 10% 4882
iter 39K 20, Carbon, 482
Retor, 47 OHM, 2W, Carbon, 10% 4883
Ruiter, 33 OHM, 3, Carbor, 10% ass
aitor, 38 OHM, SW. Carbon, 10% 4461
air, 220 OMA, W, Carbon, 10% asa
Poteromatar, 200 OHM, 2W. W.W. Linear O4ARA
Resior, 120 OMA, WW, Corbon, = 1084407
Renter, 120 OHM, AW, Carbon, =10% 4807
Vt Tube, 12007 on
V2 Tobe, 12007 an
VO Tobe, as ais
Va Tobe, 6866 215
V5 Tube, GT ou
Ye Tobe, SYOGT ou
111 Tronlormar, Powe, 26044 1568
112 Tronfermer, Opt ALS 1965
‘51 Raciar, Slanium, JOMA, Half Wove smu
‘3H2_ ctr, Selenium, SOMA. Brida ss
SWI Swich, Rory, AMP, 125V AC seat
Fine 3AG, 2 AMP, $10.80 22002
Tsu per sre ental fom sletonic pet dele,‘Schemauc Wiagram moce! ASU Line AmpuTIEr
WARRANTY
The Electro-Voice Model A30 amplifier is guoron-
teed against defects in workmanship ond material
ey ELECTRO-VOICE, INC. / BUCHANAN, MICHIGAN
Pete ome -AS Pint e054,f