TAT: Man DM a :2012
Display Count,
PRESS TARE and MODE POWER:
Display shoes count. Press MODE key to exit.
PARAMETER SETTING:
PRESS MODE POWER: Display Shows Pass (MODE)
DSP-0 = Display Power Saving.(MODE) -> (Yes/No) (MODE)
‘Yes= power saving mode (single 0)
No = Weight Mode
AUTO-0 = Auto Zero Tracking (MODE) -> X.0d. (where X values 0 to 9) (MODE)
DP Decimal Point Setting (MODE)
MR button to adjust Decimal Point. Once adjust press MODE key.
STEP = No of Capacity selection (MODE) -> S-X (X= 0 to 3) (MODE)
La-1 = Least Digit tor capacity 1 (Accuracy Digit)
(MODE) -> x (X=1/2/5'10/20/50'100/200/500) (MODE)
CAP-1 = Capacity 1 (MODE) 200200 enter capacity (MODE)
Ld2 = Least Digit for capacity 2 (Accuracy Digit)
(MODE) -> X (X=1/2/5'10/20/50/100/200/500) (MODE)
CAP-2. = Capacity 2 (MODE) xxx.2xx enter capacity (MODE)
Ld-3 = Least Digit for capacity 3 (Accuracy Digit)
(MODE) -> x (X=1/2/5'10/20/50'100/200/500) (MODE)
CAP-3 = Capacity 3 (MODE) 200200 enter capacity (MODE)
= Mode Setting (MODE)
Liter Mode (MODE) (Yes/No) (Mode)
SPIECE = Piece Counting Mode (MODE) (Yes/No) (Mode)
CAL| = Calibration (MODE)
CAL-0 = After Delay Shows Count (MODE)
LOAD = Put Weight on scale then (MODE)
XOX = Shows old weight entered,
‘enter the new weight which is kept on pan(MODE}
CAL-F = Display Counts (MODE)
(if Again Load Comes then please check the weight kept on scale either 0 weight or
weight is not sensing by load cell)
DONE = Gaiibration Done
‘Nome Setting:
Press MR Power
PASS N = (MODE) 0000 Enter master password "2012" (MODE}
NAME = Display shows" A”
Enter the name with help of KEY M+ (incrementing) and KEY MR(Shift)
Press MODE key to finish name entering.
DAY — = (MODE) Enter the Day lock Count (MODE)ER Ps RD. E
‘Press and hold MPLUS and Power UP :
PASS P = (MODE) 0000 Enter master password “2012” (MODE)
PASSRI Display shows * 0000"
Enter the new sub password with help of KEY M+ (incrementing) and KEY MR(Shif).
Press MODE key to change password.
CAL| = Calibration (MODE)
CAL-0 = After Delay Shows Count (MODE)
LOAD = Put Weight on scale then (MODE)
X000( = Shows old weight entered,
enter the new weight which is kept on pan(MODE)
CAL-F = Display Counts (MODE)
Load Comes then please check the weight kept on scale either 0 weight or
Weight is not sensing by load cell)
DONE = Calibration Done
LOW BATTERY ON OFF;
PRESS MPLUS AND MR and Power UP
Display Shows “LB XXX" where XXX = On or OFF, Each time it toggles value.
If last value on and u enter this selection it becomes off.