Professional Documents
Culture Documents
Unoccupied bed is a bed that does not call for any special cases. To provide
comfort for the PT.
- All you need is a bottom sheet, top sheet, 1 pillow case and a pillow
Start….
Wash your hands
- To avoid spread of microorganisms
Assemble your linens, the pillow case must be at the bottom then the top
sheet last would be the bottom sheet.
- This will be able to save time and to grasp the linens according to its
sequence
Shift the mattress up to the head of the bed
- Allow foot room and move the mattress against the head of the bed.
Place the bottom sheet at the foot part of mattress with the bigger hem in
contact with the mattress. Open the mattress and bring and extra part towards
the head part.
- This allow adequate linen to cover the opposite bed.
Unfold one side then roll it making sure to no expose the part that have
contact with the PT
- Not exposing it will avoid contamination
Then grasp one corner of the sheet and tuck the head part by lifting the bed
- This will prevent the linen from being caught by the spring of the bed.
Miter the the bottom sheet, Then tuck and make sure to stretch to avoid
bumps.
- This will help to secure the linen to not move when the bed is occupied.
Then put the top sheet from the head part bring extra part towards the foot
part.
- This allow adequate linen to cover the opposite bed.
Unfold one side then roll it making sure to no expose the part that have
contact with the PT
- Not exposing it will avoid contamination
Miter the top sheet on the foot part, then do not the sheet in
- This allow the PT to easily slip on the bed.
Fold the upper 18” of the top sheet down and make a cuff
- The cuff will makes it easier for the PT to cover up.
Make the other side of the bed with the same procedure making sure that it is
properly tucked.
- Doing the other side completely will help save time
Grasp the center of the pillow case towards the close end. Turn it inside out
and with one hand. Grab the center of one end of the pillow and pull the case
over towards the length of the pillow.
- This will allow the pillow to easily slide inside the pillow case.
Place the pillow case on the head part of the bed facing the open end away
from the entrance
- For a neater appearance.
You can draw the top sheet over the pillow to make it as a close bed. Or if not
an open bed for convenience
Secure the device signal near reach the client
- For the client to easily grab it.
Arrange the furnitures and clean the hands to avoid contamination.
Obstetrical Bed a bed prepared for the client who has given birth
All you need is a top sheet, bottom sheet, top sheet, waterproof pad, diaper