Professional Documents
Culture Documents
Boss RC-30 PDF
Boss RC-30 PDF
2011 RC-30
SERVICE NOTES
Issued by RJA
Table of Contents
Cautionary Notes ..............................................................2 Data Backup and Restore Operations ..........................14
Specifications .....................................................................2 Performing a Factory Reset............................................14
Location of Controls .........................................................4 Formatting the microSD Card .......................................14
Location of Controls Parts List........................................5 Updating the System ......................................................14
Exploded View (1).............................................................6 Test Mode .........................................................................15
Exploded View (1) Parts List ...........................................6 Circuit Board (Jack, DC Jack Board) .............................20
Exploded View (2).............................................................8 Circuit Diagram (Jack Board: Digital) ..........................22
Exploded View (2) Parts List ...........................................9 Circuit Diagram (Jack Board: Analog) .........................24
Disassembly Procedure ....................................................9 Circuit Diagram (Jack Board: Power, DC Jack Board)26
Wiring Diagram/Block Diagram..................................10 Circuit Board (Panel, XLR Board) .................................28
Parts List ...........................................................................12 Circuit Diagram (Panel, XLR Board) ............................30
Verifying the Version......................................................14
User data may be lost during the course of the procedure. Refer to Connecting
to Your Computer via USB (p. 14) in the owner’s manual and save the data. Input Impedance
After completing the procedure, restore the backed-up data to the product.
MIC IN: 4 kΩ
INST IN: 1 MΩ
AUX IN: 22 kΩ
Parts List
A component whose part code is ******** will not be supplied as a service part
Nominal Output Level
because one of the following reasons applies. - 20 dBu
• Because it is supplied as an assembled part (under a different part code).
• Because a number of circuit boards are grouped together and supplied as
a single circuit board (under a different part code).
Output Impedance
• Because supply is prohibited due to copyright restrictions. 1 kΩ
• Because reissuance is restricted.
• Because the part is made to order (at current market price).
• Because it is carried in electronic data on the Roland web site.
Recommended Load Impedance
• Because it is a package or an accessory irrelevant to the function 10 kΩ or larger
maintenance of the main body.
• Because it can be replaced with an article on the market. (battery or etc.)
Recording/Playback
Maximum Recording Time: Approximately 3 hours
Maximum Phrase Memory: 99 phrases
Circuit Diagram Number of tracks: 2
Data Format: WAV (44.1 kHz, 16-bit linear, stereo)
In the circuit diagram, “UnPop” is an abbreviation for “Unpopulated.” This
means non-mounted components. The circuit board and circuit board diagram
show silk-screened indications, but no components are mounted. Rhythm Type
Hi-Hat, Kick & Hi-Hat, Rock 1, Rock 2, Pop, Funk, Shuffle, R & B, Latin,
Percussion
Effect Type
BEND DOWN, STEP PHASER, SWEEP FILTER, TEMPO DELAY, Lo-Fi
USB Interface
USB 2.0/1.1 mass storage device class
Controls
REC/PLAY/OVERDUB pedal switch
STOP/TAP TEMPO pedal switch
MIC INPUT LEVEL knob
MEMORY DOWN button
MEMORY UP button
MEMORY WRITE button
MEMORY DELETE button
RHYTHM OUTPUT LEVEL knob
RHYTHM ON/OFF button
RHYTHM TYPE button
RHYTHM TAP TEMPO button
TRACK 1 slider
TRACK 1 SELECT button
TRACK 2 slider
TRACK 2 SELECT button
LOOP FX ON/OFF
LOOP FX TYPE button
PHANTOM switch
2
Mar. 2011 RC-30
Display
7 segments, 2 characters (LED)
Connectors
MIC IN Jack: XLR type (balanced/phantom power: DC 48 V, 10 mA)
INST IN Jack (L/MONO, R): 1/4” phone type
AUX IN Jack: Stereo miniature phone type
OUTPUT Jack (L/MONO, R): 1/4” phone type
FOOT SW Jack: 1/4” TRS phone type
USB Connector
DC IN Jack (DC 9 V)
Power Supply
DC 9 V: Alkaline (AA, LR6) or Carbon-zinc battery (AA, R6) x 6
AC Adaptor (PSA series: sold separately)
* Rechargeable Ni-MH batteries cannot be used.
Current Draw
Maximum 195 mA (DC 9 V)
* Expected battery life under continuous use:
Alkaline battery (AA, LR6): Approx. 7.5 hours
Carbon-zinc battery (AA, R6): Approx. 1.5 hours
These figures will vary depending on the actual conditions of use.
Dimensions
173 (W) x 158 (D) x 57 (H) mm
6-13/16 (W) x 6-1/4 (D) x 2-1/4 (H) inches
Weight
1.2 kg / 2 lbs 11 oz (including batteries)
Accessories
Owner’s Manual (#5100018913)
Leaflet (“USING THE UNIT SAFELY,” “IMPORTANT NOTES,” and
“Information”) (#********)
Alkaline battery (AA, LR6) x 6 (#********)
3
Mar. 2011 RC-30
Location of Controls
fig.panel.eps
6 7 3 9 5 10
a a
1
5
14
a a
11 13 13 12
6 4 8
b 21
15
20 19 18 17 16
4
Mar. 2011 RC-30
5
Mar. 2011 RC-30
2
3
a
9
a
1
8
7
8
b
6
6
Mar. 2011 RC-30
7
Mar. 2011 RC-30
10
2
9
f c
23
14
b
19
LEFT SIDE 11
RIGHT SIDE 12
21
17 18
3
h i
13
g
b
1
26
k
24 25
16 6
20
7
8
4
15 d
20 a
8
Mar. 2011 RC-30
Parts
No. Part Code Part Name Description Q’ty
1 5100018735 CASE 1
2 5100018736 PANEL 1
3 5100018737 LED PANEL 1
4 5100018738 REAR PANEL 1
5 5100018739 ESCUTCHEON 1
6 5100018740 7SEG COVER 1
7 5100018741 RUBBER SW 1
8 5100018742 POT DUST COVER 1
9 03344934 R-KNOB (G2477122/75D522N0R0) 2
10 F2477102R0 S-KNOB 2
11 75D422T1R0 PEDAL L 1
12 75D422T0R0 PEDAL R 1
13 5100018744 INSULATING SHEET CENTER 1
14 5100018745 INSULATING SHEET BOTTOM 1
15 5100007817 LED GUIDE (G2197126R0) 1
16 5100018743 LED SPACER 1
17 04560601 CUSHION R (G2357111) 2
Screws
No. Part Code Part Name Description Q’ty
a 40012489 SCREW 2.6X10 BINDING TAPTITE P FE BZC 2
b 5100008242 SCREW 3X6 (H5019110R0) PAN TAPPING B1 ZC 13
c 5100008244 SCREW M4X8 (H5029855R0) HEXAGON BUTTON HEAD FE NI 4
d 5100003926 PLAIN WASHER 9X13.5X0.5T NI (H5039158R0) 5
e 5100003918 JACK NUT M9X12X2 NI RTC (H5039510R0) 5
f 40128923 HEX NUT M7 2
g 5100008086 INT TOOTH WASHER 9.5X12.5X0.5 NI RTC (H5039205R0) 5
h 5100008241 BTN M4D3 BOLT BZC (H5029852R0) 2
i 5100008291 RESIN WASHER 4.1X7.5X0.5 BK (H5039413R0) 2
k 5100008293 RESIN WASHER 5.1X9.5X0.5 BK (H5039414R0) 2
Disassembly Procedure
Disassemble in the sequence of Exploded View (1) (p. 6), then Exploded
View (2) (p. 8).
* When replacing the LED on the Panel Board (No. 20), it is not necessary to
remove the Escutcheon (No. 5).
* When the 7-segment Cover (No. 6) has been removed, then 7-segment LED
display can be changed while the Panel Board remains installed on the Case
(No. 1).
9
Mar. 2011 RC-30
10
Mar. 2011 RC-30
fig.BLOCK.eps@R
11
Mar. 2011 RC-30
Parts List
fig.-part1-e.eps
Note: The parts marked # are new. (initial parts) The description “Q’ty” means a necessary number of the parts per one product.
CASING
# 5100018735 CASE 1
# 5100018737 LED PANEL 1
# 5100018736 PANEL 1
# 5100018740 7SEG COVER 1
# 5100018739 ESCUTCHEON 1
75D422T1R0 PEDAL L 1
75D422T0R0 PEDAL R 1
# 5100018738 REAR PANEL 1
5100008053 BOTTOM COVER (75D422E0R0) 1
5100008058 TWIN BATTERY CASE V6 (G2017620R0) 1
5100008056 BATTERY COVER (G2017621R0) 1
KNOB, BUTTON
03344934 R-KNOB (G2477122/75D522N0R0) 2
F2477102R0 S-KNOB 2
# 5100018741 RUBBER SW 1
SWITCH
5100011813 SWITCH (F3159712R0) SV69010F-0202-6V-NP-001 1
13129778 TACT SWITCH SKQKAHD010 2
PWB ASSY
# 5100017360 JACK SHEET ASSY 1
* This unit includes the following parts.
# ******** JACK BOARD 1
# ******** DC JACK BOARD 1
DIODE
03349989 LED (GREEN) L-34GDSL-FPB 3
15029281 LED (RED) GL-3PR8 7
5100007408 LED (F5339532R0) 19-226SURSYGC/S530-A3/E2/TR8 1
5100007410 LED (F5339534R0) 19-21/R6C-AL2N1VY/3T 5
# 5100021083 LED SA39-11SURKWA-3.3 2
F5029126R0 LED L-113GDT-F01(GREEN) 1
POTENTIOMETER
5100001448 POTENTIOMETER (F3279802R0) RD901F-40-125F-B50K-00D 1
# 5100018308 ROTARY POTENTIOMETER RD901F-40-125F-A50K-00DQ8 1
# 5100019563 SLIDE POTENTIOMETER RA2043F-20-10C1-B50K-C 2
WIRING, CABLE
5100010465 WIRING 3P L=53X6X6MM P=2.0 1
5100007871 WIRING L=80MM 2P (G3487163R0) 1
# 5100018920 WIRING W1 (MIC) 1
# 5100019608 WIRING W2 (MAIN) 2
12
Mar. 2011 RC-30
SCREWS
5100008243 SCREW 2.6X5 (H5019430R0) BINDING HEAD TAPTITE P FEZC 2
40012489 SCREW 2.6X10 BINDING TAPTITE P FE BZC 2
5100008242 SCREW 3X6 (H5019110R0) PAN TAPPING B1 ZC 13
5100008245 SCREW 3X8 (H5019115R0) PAN TAPPING B1 BZC 7
5100008241 BTN M4D3 BOLT BZC (H5029852R0) 2
5100008244 SCREW M4X8 (H5029855R0) HEXAGON BUTTON HEAD FE NI 4
40128923 HEX NUT M7 2
5100003918 JACK NUT M9X12X2 NI RTC (H5039510R0) 5
5100008291 RESIN WASHER 4.1X7.5X0.5 BK (H5039413R0) 2
5100008293 RESIN WASHER 5.1X9.5X0.5 BK (H5039414R0) 2
5100008086 INT TOOTH WASHER 9.5X12.5X0.5 NI RTC (H5039205R0) 5
5100003926 PLAIN WASHER 9X13.5X0.5T NI (H5039158R0) 5
MISCELLANEOUS
5100008055 PEDAL PLATE 62X53 (G2357116R0) 2
5100008237 PEDAL SHAFT (H5029851R0) 2
5100008052 BOTTOM FOOT (G2357118R0) 2
5100008059 BATTERY TERMINAL (+) (G2177308R0) 1
5100008061 BATTERY TERMINAL (-) (G2177309R1) 1
5100008060 BATTERY TERMINAL (+/-) (G2177307R1) 1
# 5100018870 BOTTOM LABEL 1
5100007504 COIL SPRING (22177109R0) 2
5100008057 BATTERY INSULATING SHEET (G2257130R0) 1
# 5100018745 INSULATING SHEET BOTTOM 1
# 5100018744 INSULATING SHEET CENTER 1
5100007817 LED GUIDE (G2197126R0) 1
5100003409 LED SPACER LEDS-8S 1
# 5100018743 LED SPACER 1
5100008054 PEDAL FOOT (G2357115R0) 2
5100007505 PEDAL GUIDE BUSH (22157702R0) 2
04560601 CUSHION R (G2357111) 2
# 5100018742 POT DUST COVER 1
ACCESSORIES (Standard)
# 5100018912 OWNER’S MANUAL JAPANESE 1
# 5100018913 OWNER’S MANUAL ENGLISH 1
13
Mar. 2011 RC-30
• Recording -> overdubbing -> playback selection-sequence setting (initial The update operation starts.
value: rd) When the update finishes, the message OK appears on the 7-segment
This data is initialized when a factory reset is executed. LED display.
14
Mar. 2011 RC-30
Items Required
• Noise meters x 2
Selecting or Skipping Test Items
• Oscilloscope x 1 Selecting and executing a specific test item is not possible. Skipping test items
• AC adaptor (PSA series device) x 1 is also not possible.
• Signal generators x 2
• Stabilized power supply or battery set at 5.8 V
• Testers x 2 Meanings of Error Codes
• 47-kΩ dummy plugs (1/4-inch phone type) x 2 Error code Problem location
• FS-5 x 2 E1 Serial flash IC3
• Computer (running Windows) x 1 E2 SDRAM IC2
E3 MicroSD CN3
• USB cable x 1
E4 USB JK1
• DI-1 x 1 E5 DSP IC1
• 2.2-kΩ load plug (XLR; 2.2-kΩ connected between hot and ground and Er Incorrect switch pressed
between cold and ground), or 1-kΩ load plug
5. Verify that current consumption is not more than 160 mA (or 170 mA).
DC Power Supply: 9V
6. Set the PHANTOM switch to OFF and verify that the TAP TEMPO LED
turns green.
2. Adjust the TRACK 1 and TRACK 2 sliders and the RHYTHM OUTPUT
7. Depress the left pedal to advance to the next test item.
LEVEL control to minimum.
3. Hold down the buttons indicated below and insert a plug into the
OUTPUT L/MONO jack.
• Mode for executing all tests: TAP TEMPO and
• Mode for executing 7. DA Test (A1) (p. 16) and subsequent tests:
TAP TEMPO and
When the power comes on and the Test Mode starts correctly, a reading
like the one shown below appears on the 7-segment LED display.
• Mode for executing all tests: Version (REC LED illuminated)
• Mode for executing 7. DA Test (A1) (p. 16) and subsequent tests: A1
* Continue to hold down TAP TEMPO and (or ) until one of the
displays just described appears. This takes approximately 2 seconds after the
power is switched on.
15
Mar. 2011 RC-30
2. Press each button in the sequence shown in the table below, and verify 2. Depress the FS-5U connected to the FOOT SW jack (tip end).
that the corresponding LED lights up. The reading on the 7-segment LED display changes to F2.
When the values from MIN to MAX have been detected correctly,
execution automatically advances to the next VR (potentiometer) test.
When the values from MIN to MAX have been detected correctly,
execution automatically advances to the next VR (potentiometer) test.
5. Verify that r0 is shown on the 7-segment LED display.
6. Slowly turn the RHYTHM OUTPUT LEVEL control from MIN to MAX,
and verify that the reading on the 7-segment LED display changes as
shown below.
r0 -> r1 -> r2 -> r3 -> r4 -> r5 -> r6 -> r7 -> r8
* When the control is at center, r4 is displayed.
When the values from MIN to MAX have been detected correctly,
execution automatically advances to the next test item.
16
Mar. 2011 RC-30
4. Disconnect the plug from the OUTPUT R jack and verify that the 8. Make the following settings on the DI-1.
waveform on channel 1 changes. ATT: 0 dB, Ø: NOR, GND: NOR
fig.audio-3.eps
9. Make the following settings on the oscilloscope.
Channel 1 (OUTPUT L): 2.00 V/DIV, 1.00 ms/DIV
Channel 2 (OUTPUT R): 2.00 V/DIV, 1.00 ms/DIV
Coupling: DC
10. Adjust the MIC INPUT LEVEL control to the minimum setting (OFF) and
verify that no waveform is produced.
fig.audio-6.eps
4. Verify the waveforms on channel 1 and channel 2. Also verify that the
peak value is at 450 to 550 mVp-p.
fig.audio-4.eps
12. Verify that the peak indicator starts to light up when the MIC INPUT
LEVEL control is near the one o’clock position.
13. Adjust the MIC INPUT LEVEL control to the maximum setting and verify
that the peak value is at 7.8 to 8.5 Vp-p.
fig.audio-8.eps
5. Disconnect the plug from the INST IN R jack and verify that the
waveforms on channel 1 and channel 2 change. Verify that the peak value
is at 450 to 550 mVp-p.
fig.audio-5.eps
7. Input the following signal to the MIC IN connector (using the DI-1).
200-Hz sine wave at 200 mVp-p
17
Mar. 2011 RC-30
14. Disconnect the plugs from the INST IN L and R jacks. 13. Battery Detection Circuit Test
15. Input the following signal to AUX IN.
1. Connect the stabilized power supply (5.8 V) to the DC jack.
200-Hz rectangular wave at 250 mVp-p (L and R)
* Alternatively, connect a battery set at 5.8 V to the battery snap. When doing
16. Verify the waveforms on channel 1 and channel 2. Also verify that the this, connect nothing to the DC jack.
peak value is at 550 to 650 mVp-p.
fig.audio-9.eps 2. Insert a plug into the OUTPUT L/MONO jack.
The power comes on.
2. Insert a plug into the OUTPUT L/MONO jack, and verify that the unit
starts without problem.
17. Depress the left pedal to advance to the next test item. 3. Disconnect the plug from the OUTPUT L/MONO jack.
The power is switched off.
18
Mar. 2011 RC-30
19
Mar. 2011 RC-30
20
Mar. 2011 RC-30
fig.b-JACK-2.eps
21
Mar. 2011 RC-30
8
7
6
5
MA(0:1
RA9
10k
1
2
3
4
D+3.1 RA8
22
1 4 5 C20 H19
2 3 6 D20 K18
3 2 7 E19 K19
4 1 8 F19 M18
5 G20 M19
6 R38 22 L20
7 L21
TO JTAG BOARD 8 1 8 M20 R8 0 XSF-WP
9 2 7 B19 M21 XSD-PWR
10 3 6 C21
11 4 5 B20 Y15 R47 33 MA(15)
12 A20 AA15 MA(14)
13 XREST RA18 22 B21 W16 R46 33
14 V17
D+3.1 D+1.2 U18 1 8 MA(11)
CN2 AA14 2 7 RA7 MA(10)
14FMN-BMTTN-A-TF (LF)(SN) DGND C18 AA19 3 6 33 MA(9)
UnPop Y19 4 5 MA(8)
AA18 4 5 MA(7)
4 1 C4 C3 V16 3 6 RA6 MA(6)
VDDTRI-STATE 1uF 0.1uF B18 V14 2 7 33 MA(5)
W14 1 8 MA(4)
C10 AA12 4 5 MA(3)
0.1uF 2 3 R21 10 DGND A19 Y13 3 6 RA5 MA(2)
GND OUT AA13 2 7 33 MA(1)
IC5 D+3.1 Y14 1 8 MA(0)
DSCB48.0000MNS
DGND B3 P19 1 8 MD(15)
C4 P18 2 7 RA4 MD(14)
B6 T19 3 6 33 MD(13)
T18 4 5 MD(12)
C22 V20 1 8 MD(11)
C6 C5 V19 2 7 RA3 MD(10)
10uF 0.1uF 0.1uF D5 U20 3 6 33 MD(9)
TP33 D+3.1 TP28 TP30 A6 U19 4 5 MD(8)
TP27 TP29 C7 T21 4 5 MD(7)
T20 3 6 RA2 MD(6)
SF-WR DGND R21 2 7 33 MD(5)
VR2 R149 0 A3 R20 1 8 MD(4)MD(3)
VR1 R41 0 B4 P21 4 5
MD(2)
1 R18 100 C5 P20 3 6 RA1
MD(1)
2 R16 33 D6 N21 2 7 33 MD(0)
3 R15 33 VR0 R40 0 A4 N20 1 8
4 R14 33 B5
5 R17 10 C6 E18
6 R20 33
PVCC A5 H18
7
8 D ( 0.5% )
R187 330k
C123UnPop
C19 UnPop
C20 UnPop
A13
CN1
08FMN-BMTTN-A-TF (LF)(SN) TP31 R235 F21 B13
UnPop C2 2 UnPop F20
0.1uF TP32 1
SF UPDATE 3 C14
D ( 0.5% )
IC14 E21
R227 100k
C15
R53 UnPop
R32 150k
RA16 33
R51 0
10
20
3
2
1
4
RA17 33 DGND DGND
F3 C19
SF-WR F2 R30
0
C2 L1 120k
A8 1 4
R33
ACM2012-900-2P-T002
B8 2 3
B1
D10 D+3.1
UnPop
R37
Y1 C11
A7 1uF
EZJZ1V500AA R34
EZJZ1V500AA R35
EZJZ1V500AA R36
0.1uF
B2
0.1uF
10uF
10uF
D9
C9 D+1.2
R49 R56 R50 B9 C7
C8
A2 B11
C12
C13
XMWR_CAS
C9
6
7 C154
5 0.1uF IC14
4
IC14 NJM2115V(TE1)
DGND NJM2115V(TE1)
DGND
TP1
D+3.1
TP4 TP5 TP8 TP15 TP16
TP3 TP6 TP7 TP9 PVCC AVCC+48V D+3.1 TP14 TP17
TP19 TP21 TP54
1 TP18 TP20 TP147
2
3 R177 0 XSW-DATA0 1
4 R178 0 XSW-DATA1 2
5 R169 0 XSW-DATA2 3
6 R160 0 XSW-DATA3 4 R199 0 MIC-OUT
7 R151 0 XSW-SCAN0 5
TO PANEL BOARD 8 R152 0 XSW-SCAN1 6
9 R157 0 XSW-SCAN2 7 R192 0 XPHANTOM-SW
10 8 R27 0 PHANTOM-ON
11 9 R221 0 XPWR-LED
12 R176 0 LED-D0 TO PANEL BOARD 10 R179 0
13 R161 0 LED-D1 XPEDAL-L-SW
14 R150 0 LED-D2 11 R186 0 XPEDAL-R-SW
15 12
16 R175 0 LED-CK 13 R183 0 VR0
14 R188 0 VR1
CN8 15 R174 0 VR2
A2001WR2-16P 16
DGND
CN7 DGND AGND
Right Angle TP11 TP13 A2001WR2-16P TP22 TP24
TP2 TP10 TP12
TP35 TP36 TP23
Right Angle
22
Mar. 2011 RC-30
fig.d-JACK-Digital.eps@R
MD(0:15)
15)
TP37
IC7
TC7WU04FU(TE12L.F) R104 IC7
1M TC7WU04FU(TE12L.F) R93 D+3.1
3 5
1 7 6 2 22
IC7
DGND TC7WU04FU(TE12L.F)
R103
10k
10k
10k
680
D+3.1 1 3 D+1.2
R71
R72
R91
X1
E3SB16.9344F12D33 D3 Y4
2
4
C69 C70 Y5
VCC
W5
8
15pF 15pF
C67 C63 V5
IC7 1uF 0.1uF D2 W3
C65 U4
GND
0.1uF TC7WU04FU(TE12L.F) V3
DGND
4
DGND C1 U2
U1
D+1.2 U3
DGND E2 T1
UnPop C62 V1 4 5 XBYPASS
UnPop C56 R12 V2 RA19 3 6 XPHANTOM-SW
C57 22pF 2.7k C68 C66 W1 100 2 7 XPEDAL-R-SW
C59 22pF 1uF 0.1uF E3 W2 1 8 XPEDAL-L-SW
C58 22pF
C61 22pF
DGND E1
SD CARD C60 22pF DGND V12
W12
CN3 RA22 100 H4 V11
SCHB1B0100 LED-D2 1 8 H3 W11
12 LED-D1 2 7 J4 V9
COVER 11 DGND LED-D0 3 6 J3 W9
COVER 10 LED-CK 4 5 G2 V7
(GND) 9 R211 100 G1 W7
(GND) 8 R215 100 H2 AA8
DAT1 7 R209 100 R92 22 H1 Y8 4 5 XSW-DATA3
DAT0 62 R210 100 SDCD3 1 8 J2 AA9 RA10 3 6 XSW-DATA2
CARD SDCD2 2 7 J1 Y9 100 2 7 XSW-DATA1
VSS(GND) 61 SDCD1 3 6 K2 AA10 1 8 XSW-DATA0
CLK 54 SDCD0 4 5 K1 Y11 FSW-IN
VDD 3 RA21 22 AA11 R9 100
CMD Y12
CD/DAT3 21 SDCCMD R87 22 L3
DAT2 L2 RA15 100
LRCK R79 100 L1 4 5
SD+3.1
L4 AA6 3 6 XSW-SCAN2
R80 100
M2 Y6 2 7 XSW-SCAN1
BCK
R85
M1 AA7 1 8 XSW-SCAN0
SDCCK 47 N3 Y7
N2 Y2
MCK R84 100 N1 AA4
N4 R61 100
C64 XPWR-LED R222 100 R4 D9 1SS387(TPH3.F)
C54 0.1uF
10uF XCPU-PHANTOM R86 100 R3 D6 1SS387(TPH3.F)
16V SD-AD T2
SD-DA R78 100 P2
XDA-MUTE R223 0 R2
DGND XCODEC-PDN R1
IC1
MB8AA4181(ESC2)
D+3.1
D+3.1 D+3.1
C84
0.1uF D+3.1 D20 D+3.1 D13 R26
R62 1SS362FV(TPL3) 1SS362FV(TPL3) UnPop
10k D14
FSW-IN 2 1 R133 0 1SS362FV(TPL3)
R132 R134 0 2 1 D+3.1
2 1
3
0 Q4 1 R219
DGND
3
3
XSD-PWR R124 10k 1 Q23 2 1k DGND
SSM3J108TU (TE85L) DTC114TUAT106 4
R44 47k
2
FOOT SW 3
3
SD+3.1 TP38 1
JK8 R220
HTJ-064-22H 1k
UnPop
C86
UnPop
C88
DGND DGND
D+1.2
DGND
1 XCPU-PHANTOM
2
DGND
23
Mar. 2011 RC-30
3
AGND Q6 TP50 1800pF D ( 0.5% )
TP41
2
2SK880-GR(TE85R.F) TP51
2 R89 0 3 R156
4 C97 22k
3 R147 C128 R52 56k D ( 0.5% )
C73 UnPop 10uF 16V D ( 0.5% ) C105
1
R115
1 10k 1uF 2 10uF 16V
1M
JK4 TP53 1
IN-AVREF TP55 3
UnPop
HTJ-064-22H
C81
IN-AVREF2
R154
AGND C99 R60 3.9k IC12
10k
4700pF D ( 0.5% ) R75 0 NJM2115V(TE1)
C89
AGND R159 22k 10uF 16V
AGND D ( 0.5% )
2 1 Q10
2SK879-Y(TE85R.F)
3
D10 UnPop
MAX INPUT: +8.0dBu TP56
UnPop
AVCC TP150 TP59 TP65 TP66
D5 C171
1SS362FV(TPL3) R164 56k
2SK880-GR(TE85R.F)
Q7
1 1uF D ( 0.5% )
R116
6
JK6
1M
7
HTJ-064-22H IN-AVREF 5
UnPop
C78
AGND
R143
IN-AVREF2 IC12
10k
TP61 NJM2115V(TE1)
TP60
C55 R11 3.9k
AGND 4700pF D ( 0.5% ) R74 0
AGND
R166 22k
D ( 0.5% )
2 1 Q25 MIC, INST:[-8.1dB]
2SK879-Y(TE85R.F) AUX:[0dB]
D11 3 UnPop
UnPop TP62
AVCC
UnPop
R48
DTA114EUAT106 (PB FREE)
2
R182
1 UnPop C153
UnPop
Q22
3
TP45
UnPop
AGND
AGND
AVCC
D ( 0.5% ) D ( 0.5% )
10uF 16V
AUX IN IN-AVREF2
3
AGND
10k
10uF 16V
R113
2 R102 0
10k
3
1 R126 0
C111
10uF 16V
10uF 16V
R118
R127
HSJ0857-0162109
C113
C93
10uF 16V
12k
10k
2 1
AGND D1
MAX INPUT: +0.37dBu 1SS362FV(TPL3) AGND
C151 C152 R106 R107 AGND AGND
AGND 220pF 220pF 100k 100k
24
Mar. 2011 RC-30
fig.d-JACK-Analog.eps@R
AVCC
TP95
TP82 TP88 Q5 TP97
UnPop
3
TP96
C127 R66 22k 2 1
UnPop
10uF 16V D ( 0.5% ) R24
D4
2
R23 UnPop UnPop
C141 R101 0
10uF 16V R98 0
3
3 C186 XBYPASS
1
1
R64 22k UnPop
D ( 0.5% ) 2 1 Q12
2
DTC114TUAT106
3
Q3 AGND UnPop
A+3.3 UnPop
TP98 DGND
R111
TP69
4.7
TP78 TP79
TP70
C75
C106 C126 47pF
10uF 16V 10uF 16V
TP72 TP77 R162 10k C124
TP67 TP68 TP73 TP76 D ( 0.5% ) 1800pF TP83
TP74 TP80
C131 C149 Q18
5
4
2 19 D ( 0.5% ) 1k
2 10uF 16V
LIN LOUT 1 R94 0 2
R165 22k 2 1 3 4
UnPop
AVREF 3
C72
IC13
3
D ( 0.5% )
UnPop
1 20 1
R96
BD7562F-E2
C147
100k
RIN ROUT
JK3
SD-DA 13 8 C94
SDTI SDTO 10uF 16V HTJ-064-22H
14 R136 AGND
LRCK 100 TP75 TP84 TP85
MCK 15 LRCK TP90 AGND AGND JACK-GND
BCK 16 MCLK C79
BCLK
R19 470k
47pF
R43 470k
7
DEM1
SD-AD MAX OUTPUT: +8.0dBu
6 R158 10k C125
DEM0
17 18 D ( 0.5% ) 1800pF
XCODEC-PDN PDN TP71 AVREF TP86
VCOM
C102 10uF 16V
TP89
C142 0.1uF
12 TP87
11 CKS3
10
9
CKS2
CKS1
CKS0
Q17
2SK879-Y(TE85R.F)
R55 56k
D ( 0.5% )
C95
R173 OUTPUT R
VSS
6 10uF 16V 1k
7 R95 0 2
IC8 2 1 AVREF
5 4
C145 UnPop
AK4556VT-E2
UnPop
3
C77
IC13
3
R97
BD7562F-E2
100k
JK5
C136 HTJ-064-22H
0.1uF AGND
DGND TP91 [+8.1dB] AGND AGND
AGND
DAC max:-0.37dBu
ADC max:-0.37dBu
ADC DR:103dB typ. DAC DR:106dB typ. 1 2
3
D15
1SS361FV(TPL3,Z)
AVCC
A+3.3
TP93 TP92
DTC114TUAT106
R109
C148 0.1uF
100k
8
1 C130 AVCC
4
XDA-MUTE 0.027uF
2
D ( 0.5% ) D ( 0.5% )
AGND TP144
AVREF
0.1uF
R114
AGND
10k
DGND
IC13
BD7562F-E2
C140
4
R119
10k
C82
10uF16V
AGND
25
Mar. 2011 RC-30
R190
CN6 MINISMDC075F-2
53014-0210
1 BATT+
CN6
53014-0210 2 BATT-
TP103
TP106 TP105 TP122
R31 0
D8
Q14
CN4 SS14 MCH6306-TL-E
JK7 WIRING RIBBON 3P/AWG26/P2.0 1 3 S D4
KM02009BB 4
2 1 1 UnPop
2 4 TP113 D3 6
1 2 2 L6 D2 5 C146
3 3 3 R212 D1 2 220uF
2
WQT-0460 1
G
33k 16V
CN5 1 C23
R214
3
WIRING RIBBON 3P/AWG26/P2.0 0.1uF TP114
EZAEG3A50AV
C71 0.1uF
R88 0 R185
ADAPTOR BOARD R213 220k
3
R207
33k Q15
DGND 2SA1832-GR(T5L.F.T) 0
D3
Ribon Cable 22k
DGND
JACK-GND
QS5U27TR(PB FREE)
TP142 D+1.2 TP140
PVCC FB-D1.2
Q13
L4 47uH
ELL6SH470M R100 0
TP137 FB-D1.2 2 5
1
C156 0.1uF
C144 10uF
LV5655VB-TLM-E
QS5U27TR(PB FREE)
TP136 FB-D3.3 IC11
FB-A3.6
22uF 16V
D ( 0.5% ) D ( 0.5% )
C165
R191 0
TP139 C155
Q13
6
7
R196
TP138 0.1uF
5.6k
DGND
3
D ( 0.5% )
SCP
VCC
C162
C161 R193 0
2 16
R200
VREF VBAIAS
4700pF
C51
C160
22k
D ( 0.5% ) D ( 0.5% )
1uF
R205
R194 0
TP135
1.5k
0.01uF 24 12
R197
27k
23 IN1- OUT1 11
100pF
22 13
6.8k
IN2- OUT2
4700pF
21 14
C158
FB2 OUT2N
R195
4 8
4.7k
D ( 0.5% )
R189 5.6k
R168 5.1k
0.01uF
VS(PGND)
17 S D4
1 CTL(STBY) 4 D3 6 0
D2 5
SGND
RT
R201
22uF 16V
3
18
10
C167
56k
D24
D ( 0.5% )
Fosc=214kHz
DGND
PVCC
QS5U27TR(PB FREE)
IC6
PVCC R82
S-80934CNMC-G84T2G 47k
2 1 DGND
VDD OUT
3 4 TP146 TP148
0.1uF
CD
VSS NC
C175
A+3.6
FB-A3.6
Q27
L5 47uH
ELL6SH470M
5
4700pF
2 5 R138
C174
R99
QS5U27TR(PB FREE)
1
0 10k
4
22uF 16V
C137 0.1uF
Q27
C164
DGND
3
R206
0
DGND
C182 0.1uF
C185 0.1uF
D+3.1
C184 0.1uF
C98 0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
C87 0.1uF
C92 0.1uF
C159
C166
C133
C157
C96 0.1uF
26
Mar. 2011 RC-30
fig.d-JACK-Power.eps@R 2SC4116-GR(TE85R.F)
3 2
R198
3.3k
1
C132 0.1uF
C90
100uF
C91 16V
220uF
16V
AGND
PVCC L2
68uH
CDRH4D28NP-680NC-R C100 0.1uF
R122 470k
1M
C101
C120
1uF
47uF
16V
R130
TP126 TP127
DGND DGND
TP132
7
8
6
R145
CTRL FB R121
100k
1 2 UnPop
1 NC APD 16
XCPU-PHANTOM MON
GND
GND
PAD
LT3482EUD#TRPBF
68k
TP133
9
R146
DGND
R148
1k
4.7k
R129
UnPop
DGND
TP100
IC9 A+3.3
NJM2882F33-TE1
1 5
VIN VOUT
3 4
GND
CTRL N-BP
0.01uF
2
C172
C50
1uF
D+1.2 D+3.1 SD+3.1 A+3.3 AVCC AVREF +48V
C163 C168 C169 C180 C173 C177 C178 C179 C18 C150
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
AGND 0.1uF 50V 50V
27
Mar. 2011 RC-30
28
Mar. 2011 RC-30
fig.b-PANEL-2.eps
29
Mar. 2011 RC-30
JK1
XLR BOARD
JY-5033A*030
SW1 SV69010F-0202-6V-NP-001
SW1 11
FBMA-10-160808-601T
FBMA-10-160808-601T
SV69010F-0202-6V-NP-001 13 12
G
2
3
1
SW1
SV69010F-0202-6V-NP-001
SW1 SV69010F-0202-6V-NP-001
21 CN4
23 22 B2011H02-5P
10
20
1 1
2 2
R24 0 3 3
L1
L2
4 4
5 5
CN3
1000pF
1000pF
A2001WR2-5P
C13
C39
TP86 TP89 TP90 Right Angle
TP87 TP88
Board In Wiring
Straight Angle
TP14
B2011HR2-16P DGND
8
VDD
DGND TP16 15 1 8 10
COM
COM
Q11 14 2 7 RA2 9 A
TP9 TP10 TP12 R61 33 2
DATA
Q10 13
Q9 12
3 6 7
5
B
C
LED1
Board In Wiring TP11 TP13 Q8 11
4 5 820 SA39-11SURKWA-3.3
R64 33 3 1 8 4 D
CLOCK Q7 10 2 7 RA4 2 E
Right Angle Q6 9 3 6 1 F
Q5 8 4 5 820 6 G
Q4 7 1 8 D.P
C28 Q3 6 2 7 RA3 TP150 TP149 TP152 TP153
UnPop Q2 5 3 6 TP151 TP148 TP155 TP154 D+3.1
Q1 4 4 5 820
VSS
Q0
TP17 IC4
3
BU2090FS-E2 10
1
COM
COM
9 A
DGND TP33 TP31 TP34 7 B
TP35 TP30 TP32 5 C LED2
DGND 4 D
D+3.1 C29 TP39 TP40 2 E SA39-11SURKWA-3.3
0.1uF TP37 TP41 1 F
6 G
16
15 1 8 TP130
Q11 14 2 7 RA1 TP129 TP131
R59 33 2 Q10 13 3 6 820
DATA Q9 12 4 5
R60 33 3 Q8 11 D+3.1
CLOCK Q7 10 R3 820
Q6 9 R6 820
Q5 8 R11 820
Q4 7 R53 470
C27 Q3 6 R55 470 LED19 L-34HDSL
UnPop Q2 5 R5 100 2 1
Q1 4 R4 470 REC
VSS
Q0 LED11
TP23 IC1 2 1 L-34GDSL TRACK1-PLAY
BU2090FS-E2
1
30
Mar. 2011 RC-30
fig.d-PANEL-XLR.eps@R
+48V C14
0.01uF TP95 MIC INPUT LEVEL VOL
TP96
R36 100k TP106 TP137 TP107
Q3 AVCC C4
2
R17 100k 10uF
2SA1587-GR(TE85L.F) 1
2
TP104 16V
3
TP103 1 3
Q4 1 PHANTOM-ON
3
D ( 0.5% )
D ( 0.5% )
D ( 0.5% ) 50kA
2
AVCC C16 R81 1k
R54
R58
3.9k
3.9k
D15
TP98 AGND UnPop C21 47pF 0.018uF D ( 0.5% ) R18 220k
TP92 R82 220k 2 1
TP101 C24 R56 5.6k C37 47pF
TP91 TP138 TP156 TP110 UnPop 2
TP124 R44 R45 D ( 0.5% )
3
6.8k 6.8k AGND 1 6
AGND 3 7
3/4W 3/4W IC5 5
R41 C31 R79
3
C11 Q5 BD7562F-E2 MIC-AVREF
3
R27 0 100 10uF 16V 100 1 2SC4116-GR(TE85R.F)
R25 0 1
D ( 0.5% )
R28 4.7k
22uF 63V TP163 Q6 TP105 IC5
C8 220pF C7 220pF
R26 0 MIC-AVREF
2
2SC4116-GR(TE85R.F)
2
TP99 R33 MIC-AVREF BD7562F-E2
R51
3.3k
C9
C6 220pF
TP100 10k C1
TP165 47pF
22uF 6.3V R78 820
R34
R52
D ( 0.5% )
3.3k
10k AGND D ( 0.5% )
D ( 0.5% )
AGND
R65 4.7k
DGND C12
R63 4.7k
TP94 TP161 TP162
R21 0 22uF 63V R42 R80 VR4 50kA VR4 50kA
TP93 C38 AVCC 100 RD901F-40-125F-A50K-00DQ8RD901F-40-125F-A50K-00DQ8
3
100
10uF 16V
TP139 2
XPHANTOM-SW D14 1
10
20
TP157 UnPop AGND AGND
AVCC AGND
0.1uF
IC5 TP102
BD7562F-E2
C15
AGND
AVCC TP108 D1
1SS387(TPH3.F)
D ( 0.5% ) D ( 0.5% )
TP114
MIC-AVREF
R29
2SC4738-GR(TE85L.F)
10k
PVCC
10uF 16V
L-34HDSL
TP111 C10 UnPop
PVCC
LED12
C22
1
PEAK
10uF
R43
C23
16V
12k
R38
2
180k
R12
68k
TP116
Q1
1.2k
R76
TP112
3
AGND
1
2SC4738-GR(TE85L.F)
Q7 TP168 1 TP109
2SC4738-GR(TE85L.F) R37
2
2
47
R32
TP166 1
47k
Q2
R31 TP113
2
R40
22k
39k
1
2
C17
DGND Q8 1uF 50V
3
2SA1832-GR(T5L.F.T)
2.7k
R20
TP160
R19
100
DGND AGND
1
L-113GDT
LED22
TP115 POWER
2
PVCC
DGND
RA2043F-20-10C1-B50K-C
TP121
3
R16 0
RD901F-40-125F-B50K-00D
50kB
VR2
TP122 2
1
RD901F-40-125F-B50K-00D RD901F-40-125F-B50K-00D
VR3
2
1
R14 0
50kB
VR1
10
20
2
1
TP123 DGND
C36 0.1uF
TRACK1 VOL
C34 0.1uF
AGND FG3
31