Professional Documents
Culture Documents
RVV65D
RVV65D--C3
C3--3XR
Multiband Antenna, 694–960 and 2x 1695–2690 MHz, 65° horizontal beamwidth, 3x
Internal RET
l All Internal RET actuators are connected in “Cascaded SRET” configuration
l Uses the 4.310 connector which is 40 percent smaller than the 716 DIN connector
Electrical Specifications
Frequency Band, MHz 694–790 790–890 890–960 1695–1920 1920–2200 2300–2500 2500–2690
Gain, dBi 16.3 17.0 17.0 18.1 18.9 19.3 19.2
Beamwidth, Horizontal, degrees 71 70 67 62 60 62 65
Beamwidth, Vertical, degrees 8.1 7.4 6.8 5.6 5.0 4.3 4.1
Beam Tilt, degrees 0–10 0–10 0–10 2–12 2–12 2–12 2–12
USLS (First Lobe), dB 16 22 18 21 20 21 20
FronttoBack Ratio at 180°, dB 29 33 31 29 34 33 31
Isolation, dB 28 28 28 28 28 28 28
Isolation, Intersystem, dB 30 30 30 30 30 30 30
VSWR | Return Loss, dB 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0
PIM, 3rd Order, 2 x 20 W, dBc 150 150 150 150 150 150 150
Input Power per Port, maximum, watts 300 300 300 250 250 250 250
Polarization ±45° ±45° ±45° ±45° ±45° ±45° ±45°
Impedance 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm
Beamwidth, Horizontal
±2.5 ±1.6 ±2.3 ±4.2 ±5 ±6.3 ±4.5
Tolerance, degrees
Beamwidth, Vertical Tolerance,
±0.4 ±0.4 ±0.3 ±0.4 ±0.2 ±0.2 ±0.2
degrees
USLS, beampeak to 20° above
14 15 15 14 15 15 15
beampeak, dB
FronttoBack Total Power at
23 25 23 25 25 27 26
180° ± 30°, dB
CPR at Boresight, dB 21 21 21 18 17 18 20
CPR at Sector, dB 12 14 11 12 9 6 8
* CommScope® supports NGMN recommendations on Base Station Antenna Standards (BASTA). To learn more about the benefits of BASTA,
download the whitepaper Time to Raise the Bar on BSAs.
General Specifications
Antenna Type DualPol® multiband with internal RET
Band Multiband
Brand DualPol®
Operating Frequency Band 1695 – 2690 MHz | 694 – 960 MHz
©2016 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope. page 1 of 5
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: May 3, 2016 May 11, 2016
Product Specifications
RVV65D
RVV65D--C3
C3--3XR
Performance Note Outdoor usage
Mechanical Specifications
Lightning Protection dc Ground inner/outer conductor
Radiator Material Low loss circuit board
Radome Material Fiberglass, UV resistant
Reflector Material Aluminum
RF Connector Interface 4.310 Female
RF Connector Location Bottom
RF Connector Quantity, total 6
Wind Loading, frontal 958.0 N @ 150 km/h
215.4 lbf @ 150 km/h
Wind Loading, lateral 299.0 N @ 150 km/h
67.2 lbf @ 150 km/h
Wind Loading, rear 1125.0 N @ 150 km/h
252.9 lbf @ 150 km/h
Wind Speed, maximum 150 km/h | 93 mph
Dimensions
Depth 180.0 mm | 7.1 in
Length 2645.0 mm | 104.1 in
Width 301.0 mm | 11.9 in
Net Weight, without mounting kit 27.5 kg | 60.6 lb
Packed Dimensions
Depth 299.0 mm | 11.8 in
Length 2894.0 mm | 113.9 in
Width 409.0 mm | 16.1 in
Shipping Weight 47.4 kg | 104.5 lb
Regulatory Compliance/Certifications
Agency Classification
RoHS 2011/65/EU
China RoHS SJ/T 113642006
ISO 9001:2008
Included Products
©2016 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope. page 2 of 5
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: May 3, 2016 May 11, 2016
Product Specifications
RVV65D
RVV65D--C3
C3--3XR
BSAMNT1 — Wide Profile Antenna Downtilt Mounting Kit for 2.4 4.5 in (60 115 mm) OD round members. Kit contains one
scissor top bracket set and one bottom bracket set.
BSAMNTM — Middle Downtilt Mounting Kit for Long Antennas for 2.4 4.5 in (60 115 mm) OD round members. Kit
contains one scissor bracket set.
* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance
©2016 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope. page 3 of 5
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: May 3, 2016 May 11, 2016
Product Specifications
BSAMNT
BSAMNT--1
Wide Profile Antenna Downtilt Mounting Kit for 2.4 4.5 in (60 115 mm) OD round
members. Kit contains one scissor top bracket set and one bottom bracket set.
General Specifications
Antenna Brand Andrew®
Mount Type Downtilt mounts
Application Outdoor
Includes Brackets | Hardware
Package Quantity 1
Mechanical Specifications
Color Silver
Material Type Galvanized steel
Dimensions
Compatible Diameter, maximum 115.0 mm | 4.5 in
Compatible Diameter, minimum 60.0 mm | 2.4 in
Net Weight 3.4 kg | 7.5 lb
Regulatory Compliance/Certifications
Agency Classification
RoHS 2011/65/EU Compliant
China RoHS SJ/T 113642006 Below Maximum Concentration Value (MCV)
ISO 9001:2008
©2016 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope. page 4 of 5
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: March 21, 2016 May 11, 2016
Product Specifications
BSAMNT
BSAMNT--M
Middle Downtilt Mounting Kit for Long Antennas for 2.4 4.5 in (60 115 mm) OD round
members. Kit contains one scissor bracket set.
General Specifications
Antenna Brand Andrew®
Mount Type Downtilt mounts
Application Outdoor
Includes Brackets | Hardware
Package Quantity 1
Mechanical Specifications
Color Silver
Material Type Galvanized steel
Dimensions
Compatible Diameter, maximum 114.3 mm | 4.5 in
Compatible Diameter, minimum 61.0 mm | 2.4 in
Net Weight 4.5 kg | 9.9 lb
Regulatory Compliance/Certifications
Agency Classification
RoHS 2011/65/EU Compliant
China RoHS SJ/T 113642006 Below Maximum Concentration Value (MCV)
ISO 9001:2008
©2016 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks, respectively, of CommScope. page 5 of 5
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: January 16, 2016 May 11, 2016