Professional Documents
Culture Documents
Rear Door Kia Sorento 2010-2016
Rear Door Kia Sorento 2010-2016
pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
SORENTO(XM) > 2015 > G 3.3 GDI > Body (Interior and Exterior)
Replacement
Door Trim Replacement
• When prying with a flat-tipped screwdriver, wrap it with protective tape, and apply protective tape around the related
parts, to prevent damage.
• Put on gloves to protect your hands.
1. Using a screwdriver or remover, remove the delta cover (A).
4. Push the hook (B), disconnect the inside handle cable cage (A).
5. Push the lock pin (A), disconnect the power window connector (B).
6. Remove the door trim
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 1/9
4/7/2014 https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
• Make sure connectors are connected properly and each rod is connected securely.
• Make sure the door lock and opens properly.
• Replace ant damaged clips.
Glass Replacement
1. Remove the following parts.
A. Door trim
B. Door belt weatherstrip
C. Door delta moulding
2. Remove the glass mounting plug hole.
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 2/9
4/7/2014 https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
• Using the door switch to align the mounting hole with the hole on the door glass.
• If it is impossible, align the hole by hand after removing the motor.
• Be careful not to drop to glass and scratch the glass surface.
3. Carefully adjust the glass (B) until you can see the bolts, then loosen them. Separate the glass from the glass run and
carefully pull the glass out through the window slot.
Tightening torque :
7.8~11.8 N.m (0.8~1.2 kgf.m, 5.8~8.7 lb-ft)
Speaker Replacement
1. Remove the door trim.
2. Drill out the rivets to remove the speaker (B) from the door module.
3. Disconnect the speaker connector (A).
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 3/9
4/7/2014 https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
• Grease should be applied to areas where there is rotational parts and springs.
• Roll the glass up and down to see if it move freely without binding.
• Make sure the door lock and opens properly.
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 4/9
4/7/2014 https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
• Roll the glass up and down to see if it move freely without binding.
• Make sure the door lock and open properly.
3. Loosen the mounting bolts and nut, then remove the rear channel (A).
Tightening torque :
3.9~5.9 N.m (0.4~0.6 kgf.m, 2.9~4.3 lb-ft)
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 5/9
4/7/2014 https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
4. Loosen the door module mounting bolts and latch mounting screws
5. Remove the door module (A)
Tightening torque :
Bolt : 7.8~11.8 N.m (0.8~1.2 kgf.m, 5.8~8.7 lb-ft)
Screw : 7.8~10.8 N.m (0.8~1.1 kgf.m, 5.8~8.0 lb-ft)
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 6/9
4/7/2014 https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
• Grease should be applied to areas where there is rotational parts and springs.
• Roll the glass up and down to see if it move freely without binding.
• Make sure the door lock and opens properly.
Adjustment
Glass Adjustment
• Check the glass run channel for damage or deterioration, and replace them necessary.
1. Remove the rear door trim.
2. Carefully adjust the glass (A) until you can see the screws, then loosen them. Separate the glass from the glass run and
carefully pull the glass out through the window slot.
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 7/9
4/7/2014 https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
1. Loosen the bolts (B), then insert a shop towel between the body and striker.
Tightening torque :
B :16.7~21.6 N.m (1.7~2.2 kgf.m, 12.3~15.9 lb-ft)
• After installing the door, check for a flush fit with the body, then check for equal gaps between the front, rear, and bottom,
door edges and the body. Check that the door and body edges are parallel. Before adjusting, replace the mounting
bolts.
1. Check that the door and body edges are parallel.
2. Place the vehicle on a firm, level surface when adjusting the doors.
3. Adjust at the hinges (A):
A. Loosen the door mounting bolts slightly, and move the door IN or OUT until it aligns flush with the body.
B. Loosen the hinge mounting bolts slightly, and move the door BACKWARD or FORWARD, UP or DOWN as necessary to
equalize the gaps.
C. Place a shop towel on the jack to prevent damage to the door when adjusting the door.
Tightening torque :
B:21.6~26.5 N.m (2.2 ~2.7 kgf.m, 15.9~19.5 lb-ft)
C:33.3~41.2 N.m (3.4~4.2 kgf.m, 24.6~30.4 lb-ft)
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 8/9
4/7/2014 https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13…
https://www.kiatechinfo.com/viewer/print_pop.aspx?pos=1$4_1_3_5_2&vehicletype=Passenger&mfrcode=KM&area=KMA&langcode=ENG&modelid=XM13&mo… 9/9