Professional Documents
Culture Documents
SECTION 303-07D: Engine Ignition — 6.2L (2V) 2014 F-150 Workshop Manual
SPECIFICATIONS Procedure revision date: 10/25/2013
Material
Item Specification Fill
Capacity
Silicone Brake Caliper Grease ESE-M1C171- —
and Dielectric Compound A
XG-3-A
General Specifications
Item Specification
Engine Ignition
Firing order 1-3-7-2-6-5-4-8
cardiagn.com
Spark plug 12405
Spark plug gap 1.07-1.17 mm
(0.042-0.046 in)
Torque Specifications
Description Nm lb-in
Ignition coil-on-plug bolts 10 89
Spark plug 18 159
SE237D01.HTM~gen~ref.H... 2014-03-01
2014 F-150 Workshop Manual Page 2 sur 2
cardiagn.com
SE237D01.HTM~gen~ref.H... 2014-03-01
2014 F-150 Workshop Manual Page 1 sur 1
SECTION 303-07D: Engine Ignition — 6.2L (2V) 2014 F-150 Workshop Manual
DESCRIPTION AND OPERATION Procedure revision date: 10/25/2013
Engine Ignition
The electronic ignition system is a coil-on-plug ignition system. The coil-on-plug ignition system consists of
the:
z change low voltage signals from the PCM to high voltage pulses.
z produce the high voltage pulses to the spark plugs.
cardiagn.com
z are connected directly to the upper spark plug.
z are connected by an ignition wire to the lower spark plug.
z change high voltage pulses into a spark which ignites the fuel and air mixture.
z originally equipped on the vehicle have platinum-enhanced electrodes for long life.
SE237D02.HTM~gen~ref.H... 2014-03-01
2014 F-150 Workshop Manual Page 1 sur 2
SECTION 303-07D: Engine Ignition — 6.2L (2V) 2014 F-150 Workshop Manual
REMOVAL AND INSTALLATION Procedure revision date: 10/25/2013
cardiagn.com
Part
Item Number Description
1 12286 LH ignition wire (4 required)
2 — Ignition coil-on-plug electrical connector (part of
9D930) (4 required)
SE237D04.HTM~gen~ref.H... 2014-03-01
2014 F-150 Workshop Manual Page 2 sur 2
1. Refer to the procedures and/or exploded views in this section for any Warnings, Notices, Notes,
Materials, Specifications, and Special Tools. Items in the exploded views may not be listed in order of
removal.
cardiagn.com
SE237D04.HTM~gen~ref.H... 2014-03-01
2014 F-150 Workshop Manual Page 1 sur 2
SECTION 303-07D: Engine Ignition — 6.2L (2V) 2014 F-150 Workshop Manual
REMOVAL AND INSTALLATION Procedure revision date: 10/25/2013
Ignition Coil-On-Plug
Material
Item Specification
Silicone Brake Caliper Grease and ESE-M1C171-
Dielectric Compound A
XG-3-A
1. Remove the Air Cleaner (ACL) outlet pipe. For additional information, refer to Section 303-12 .
cardiagn.com
2. Remove the intake air resonator. For additional information, refer to Section 303-12 .
6. NOTE: When removing the ignition coil-on-plugs, a slight twisting motion will break the seal and ease
removal.
7. NOTE: Verify that the coil-on-plug spring is correctly located inside the ignition coil-on-plug boot and
that there is no damage to the tip of the boot.
SE237D05.HTM~gen~ref.H... 2014-03-01
2014 F-150 Workshop Manual Page 2 sur 2
cardiagn.com
SE237D05.HTM~gen~ref.H... 2014-03-01
2014 F-150 Workshop Manual Page 1 sur 2
SECTION 303-07D: Engine Ignition — 6.2L (2V) 2014 F-150 Workshop Manual
REMOVAL AND INSTALLATION Procedure revision date: 10/25/2013
Spark Plugs
Removal
NOTICE: The spark plug procedure must be followed exactly or damage to the cylinder head and
spark plug will result.
NOTICE: Do not remove the spark plugs when the engine is hot or cold soaked. Spark plug thread or
cylinder head damage can occur. Make sure the engine is warm (hand touch after cooling down)
prior to spark plug removal.
1. Remove the ignition coil-on-plug. For additional information, refer to Ignition Coil-On-Plug in this
section.
cardiagn.com
Lower spark plugs
3. NOTICE: Only use hand tools when removing or installing the spark plugs or damage can
occur to the cylinder head or spark plug.
NOTE: Use compressed air to remove any foreign material from the spark plug well before removing
the spark plugs.
4. Inspect the spark plug. For additional information, refer to Section 303-00 .
Installation
1. Adjust the spark plug gap as necessary. For the correct spark plug gap specification, refer to
Specifications in this section.
SE237D06.HTM~gen~ref.H... 2014-03-01
2014 F-150 Workshop Manual Page 2 sur 2
2. NOTICE: Only use hand tools when removing or installing the spark plugs or damage can
occur to the cylinder head or spark plug.
4. Install the ignition coil-on-plug. For additional information, refer to Ignition Coil-On-Plug in this section.
cardiagn.com
SE237D06.HTM~gen~ref.H... 2014-03-01