Professional Documents
Culture Documents
Using a small screwdriver, remove the If replacing the bail wire, remove oppo- Pay close attention as to the order of the
above depicted screw. These bail assem- site screw as well. It is not necessary to internal parts of the line roller assembly.
bly screws typically have thread sealant remove this screw if only a line roller The order of the components vary from
on them, so be careful not to strip them. bearing replacement is being performed. model to model. Refer to schematics.
Clean any dirt, debris, rust or corrosion If changing the bail wire, reassemble the If changing the bail assembly, attach the
on all the line roller components. components of the line roller. new bail first with screw opposite of the
line roller assembly first.