You are on page 1of 1
8- STANDARD CONTROL OPERATIONS AND OPTIONS 8.1 - Unit start/stop control ‘+ Startistop force command [CHIL_$_S|: Chiller start! stop force command can be used fo control the chiller ‘The unit state is determined based on a number of factors, state in the Network mode. including its operating type, active overrides, open, = Command set to stop: The unit is halted. contacts, master/slave configuration, or alarms triggered + Command set to start: The unit runs in due to operating conditions. accordance with schedule 1 + Remote start/stop contact status [Onoff_sw]: Start/ ‘The table given below summarizes the unit control type stop contact status can be used to control the chiller [ctrl_typ] and its running status with regard to the state in the Remote operating type. following parameters: ‘+ Master control type [ms_ctrl]: When the unit is the master unit in a two-chiller master/slave arrangement, + Operating type: This operating type is selected using the master unit may be set to be controlled locally, the Start/Stop button on the user interfac remotely or via network. Toe ‘© Start/stop schedule [chil_oce]: Occupied or Le. ‘unoccupied status of the unit ‘+ Network emergency stop command [EMSTOP]: If activated, the unit shuts down regardless of the active operating type. © General alarm: The unit shuts down due to failure, so “ative operating PE Faramater sate Resa TOF L-€ USE Rem Net ast Statop Remote Water Stardatop Network General control Unt force starvatop control time. emergency alarm pe Sate command contact” type schedule shutdown : : enable a me = Tecal of ace — rene a aie ae = retreat ave aaa near ate rete nap remote acive —asabia retork netore of ave retire etre of aie Seeupied_— deable no eat on ave aisabla no reels on ave disable no rerato on Tacal ——secupid dao no ——Tbeal en. ef_fzel rents osoupied—siseble no remota or on eat ‘e2zupied dase no te on =a Ta haven seeipied sable no nolvoet on IMPORTANT: When the unit is stopping or there isa __In case of emergency stop, all compressors are stopped at demand to stop the unit, compressors are stopped the same time. consecutively. 24

You might also like