Professional Documents
Culture Documents
Vdocuments - MX - Powerscan 2 Prosniffer xr71p Manual English
Vdocuments - MX - Powerscan 2 Prosniffer xr71p Manual English
THE DEVICE
MAIN FUNCTIONS
POWER– switches the detectors and regulates its power .
There are ten power levels – as it works mainly on 9 or 10 level.
GAIN – regulates the power of gained signal. When the
soil is normal it works mainly on level 10.
THRESHOLD – a threshold tone. In dry soil it normally
works on level 9 or 10. When the moisture is high it’s good to work under
level 8.
SIGNAL – eliminates soil mineralization.
When soil is normal it’s good to work on level 8 to 10, while the soil is
highly mineralized it’s recommended to work on level 0 to 3.
NOISE – eliminates influence of Roman pottery over the
apparatus, it’s used in combination with SIGNAL.
FAST ZERO – press this button for about 2-3 seconds
when the detector is ready to work with and the coil is over the ground.
Pressing this button eliminates ground mineralization and the detector
chooses itself the most suitable depth for searching. While press the button
“fast zero” you must
be sure there is no metal objects under the coil. We recommend press this
button every 4-5 minutes.
LOW BATTERY – if the light switches on while
operating, it shows it’s necessary to charge the battery. If it happens,
please, do not use the detector.
COIL – a coil jack.
3. Signal tone rises slowly over a small parcel and then slowly does
down. It indicates for a middles big object buried in a range of 1-2 meters.
You can make your measurements as you bury different sized object in
different range of depths at least 1meter on another for testing small coils,
and at least 4 meters for testing one or two meters coils. While working
with the detector be consistent and keep notes for all your measurements as
you point the parcel and its structure of soil, the depth of buried objects,
and the kind of the object, the settings of buttons that localize the position
of the
object…. As more experiments you make as much you will form your
professional experience.
BATTERY CHARGE
POWERSCAN 2Pro possesses a rechargeable storage battery. If a
light "Low battery" /red led/ switches on while working with the apparatus
you must spot work and recharge the battery. Plug in the jack "CHARGE"
of the charge set into electric net of
220V. After some hours the battery will be recharged. The charge set will
automatically switch off when the battery is ready so the battery can’t be
damaged if it stays longer in the charge set. When it’s ready, in the reverse
order take the jack back
of the "CHARGE".
Contact us:
www.powerline-bg.com
Mail:
sales@powerline-bg.com