Professional Documents
Culture Documents
Indian Standard
QIJARTZITE/QUARTZ FOR THE PRODUCTION
OF FERROALLOYS — SPECIFICATION
UDC 553’546:669’168
@ MS 1991
BUREAU OF INDIAN STANDARDS
MANAK BHAVAN, 9 BAHADtJR SHAH ZAFAR MARG
NEW DELHI 110002
‘way 1991 Price Group 1
Ores and Raw Material Sectional Committee, MTD 13
FOREWORD
This Indian Standard was adopted by the Bureau of Indian Standards, after the draft finalized by the
Ores and Raw Materials Sectional Committee had been approved by the Metallurgical Engineering
Division Council.
Quartzite is a major raw material in the smelting of ferrosilicon, silicon metal and silicomanganese.
A need was, therefore felt to prepare an Indian Standard for quartzite for use in submerged are furnace.
Impurities such as alumina has been restricted to allow for contribution from the reductants. Thermal
stability and mechanical strength have been considered important physical properties to ensure good
permeability of the charge column inside the submerged arc furnace for greater safety and smelting
efficiency.
No marking clause has been included in this standard since quartzite is supplied loose.
For the purpose of deciding whether a particular requirement of this standard is complied with, the
final value, observed and calculated, expressing the result of a test, shall be rounded off in accordance
with IS 2 : 1960 ‘Rules for rounding off numerical values ( revised )‘. The number of significant places
retained in rounded off value should be the same as that of the specified value in this standard.
IS 13054 : 1991
Indian Standard
QUARTZITE/QUARTZ FOR THEPRODUCTION
OF FERROALLOYS-SPECIFICATION
.
1
-.-_.’
I I
Standard Mark
I I
The use of the Standard Mark is governed by the provisions of the Bureau of Indian Standards
Act, 1985 and the Rules and Regulations made thereunder. The Standard Mark on products
covered by an Indian Standard conveys the assurance that they have been produced to comply with
the requirements of that standard under a well defined system of inspection, testing and quality
control which is devised and supervised by BIS and operated by the producer. Standard marked
products are also continuously checked by BIS for conformity to that standard as a further safe-
guard. Details of conditions under which a liccncc for the use of the Standard Mark may be granted to
manufacturers or producers may be obtained from the Bureau of Indian Standards.
Burenu of Indian Standards
BIS is a statutory institution established under the Bureau oj Indian Standards Act, 1986 to promote
harmonious development of the activities of standardization, marking and quality certification of
goods and attending to connected matters in the country.
Copyright
BIS has the copyright of all its publications. No part of these publications may be reproduced in
any form without the prior permission in writing of BIS. This does not preclude the free use, in
the course of implementing the standard, of necessary details, such as symbols and sizes, type or
grade designations. Enquiries relating to copyright be addressed to the Director ( Publications 1,
BIS.
Headquarters:
Regional Offices:
Central : Manak Bhavan, 9 Bahadur Shah Zafar Marg
NEW DELHI 110002 i 331 01
13 31
75
Western : Manakalaya,
E9 MIDC, Marol, Andheri ( East )
BOMBAY 400093 6 32 92 95