boarding the crane or getting down from it. Additional switches
shall be provided if found necessary and when asked for.
32. IDENTIFICATION OF CIRCUITS
32.1 All switches and fuses shall be adequately labelled to facilitate the identification of the circuits. All panels, controller and resistors are to be properly marked for each motion. All main and control wires shall be ferruled at both ends, as per drawing for quick identification. All elements of the controller and panels are to be clearly marked by furnishing functional nomenclature at the devices. All equipment terminals shall be numbered and tagged.
33. DISPOSITION AND HOUSING OF ELECTRICAL EQUIPMENT
33.1 Electrical Equipment Other Than Resistor Assemblies - If electrical equipment is mounted in the open, it shall be of the enclosed type in weatherproof enclosure with provision for easy access to the parts inside. 33.1.1 Control panels and other electrical equipment should be so located that there is no chance for oil from the gearboxes, to drip on them. 33.1.2 The compartment or units shall neither impede the maintenance of the long-travel drives, nor be mounted on the bridge platform occupied by the cross-travel collector gear. The thoroughfare between the different parts of the crane or between any portion of the crane and the exit platform shall. not entail passage through the compartment or be impeded by any control unit. 33.1.3 Control panels or units shall be so spaced that efficient main- tenance may be performed, and shall withstand the mechanical forces imposed by the crane under service conditions. 33.1.4 The compartment shall be constructed of steel sections and plates, or other fireproof material of adequate mechanical strength. It shall be drip proof, adequately ventilated and lit, and in addition for outdoor cranes, weatherproof. If windows are provided, wired or toughned glass shall be used and it shall be possible to cleaa all glass surfaces without danger. 33.2 Resistor Assemblies - Resistor assemblies shall be so mounted as to ensure an adequate flow of cooling air and shall be mounted outside the main contactor compartment. 33.2.1 Resistor assemblies shall not impede the maintenance of the long-travel drives or access to the plateforms of the crane, and shall be arranged so that efficient maintenance may be performed on each unit.
AAPS Advances in The Pharmaceutical Sciences Series 9 Sejal Shah, Michael A. Repka (Auth.), Michael A. Repka, Nigel Langley, James DiNunzio (Eds.) - Melt Extrusion - Materials, Technology and Drug PR
AAPS Advances in The Pharmaceutical Sciences Series 9 Sejal Shah, Michael A. Repka (Auth.), Michael A. Repka, Nigel Langley, James DiNunzio (Eds.) - Melt Extrusion - Materials, Technology and Drug PR
Azzi, R., Fix, D. S. R., Keller, F. S., & Rocha e Silva, M. I. (1964) - Exteroceptive Control of Response Under Delayed Reinforcement. Journal of The Experimental Analysis of Behavior, 7, 159-162.